Nozzle blows off rocket booster during test for NASA's Artemis program (video)
When you buy through links on our articles, Future and its syndication partners may earn a commission.
An upgraded version of one of the solid rocket boosters being used for NASA's Space Launch System (SLS) experienced an anomaly during a test June 26.
The Demonstration Motor-1 (DM-1) Static Test took place at Northrop Grumman's facility in Promontory, Utah, simulating a launch-duration burn lasting about two minutes. It was the first demonstration of Grumman's Booster Obsolescence and Life Extension (BOLE) upgrade, an enhanced five-segmented motor designed with greater lifting power for later versions of SLS.
Shortly after the spokesperson on Grumman's recording marks T+100 seconds into the test, an outburst of flames can be seen erupting form the top of the engine nozzle. A few seconds later, as another spokesperson announces, "activate aft deluge," an even larger burst comes from the rocket's exhaust, blowing nearby debris into the flames and around the test site.
"Whoa," one of the test operators said as burn continued, before audibly gasping. Beyond that in-the-moment reaction, though, the anomaly was not acknowledged during the remainder of the test, which seemed to conclude as planned.
"While the motor appeared to perform well through the most harsh environments of the test, we observed an anomaly near the end of the two-plus minute burn. As a new design, and the largest segmented solid rocket booster ever built, this test provides us with valuable data to iterate our design for future developments," Jim Kalberer, Grumman's vice president of propulsion systems, said in a statement.
SLS, NASA's rocket supporting the agency's Artemis program, was designed on the foundation of legacy systems used during the space shuttle era. SLS's core stage fuel tank is an augmented version of the one used to launch space shuttles, and the same RS-25 engines responsible for launching the space shuttles are launching to space again on SLS missions. The segments from the shuttle's solid rocket boosters are also flying again, too.
Northrop Grumman supported Artemis 1, and will support Artemis 2 and Artemis 3 with shuttle-era hardware, before transitioning to newer hardware for Artemis 4 through Artemis 8. The company's BOLE engines aren't slated to be introduced for launch until Artemis 9, on the SLS Block 2.
The upgraded BOLE engines include improved, newly-fabricated parts replacing those no longer in production, carbon fiber composite casings and updated propellant efficiencies that increase the booster's performance more than 10 percent compared to the solid rocket engines being used on earlier SLS launches.
Thursday's DM-1 BOLE test included more than 700 points of data collection throughout the booster, which produced over 4 million pounds of thrust, according to Northrop Grumman.
Whether the BOLE design will ever fly, however, is far from certain. NASA's proposed budget for 2026 calls for the cancelation of the SLS rocket following Artemis 3.
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
Yahoo
11 minutes ago
- Yahoo
Core Scientific (CORZ) Surges 33% as CoreWeave Revives Acquisition Bid
Core Scientific, Inc. (NASDAQ:CORZ) is one of the . Core Scientific rallied for a third straight day on Thursday, jumping 33.01 percent to close at $16.36 apiece following the revival of CoreWeave Inc.'s (NASDAQ:CRWV) bid to acquire the company. According to a report by the Wall Street Journal, citing people privy to the matter, CoreWeave Inc. (NASDAQ:CRWV) revived talks to acquire Core Scientific, Inc. (NASDAQ:CORZ) after its first attempt in 2024 fell through due to pricing issues. Both companies have yet to confirm or deny the reports ,but the Journal said that a deal is expected to be finalized in the coming weeks. An aerial view of an intricate network of digital infrastructure, lit up against a night sky. CoreWeave Inc. (NASDAQ:CRWV) has been instrumental to Core Scientific, Inc.'s (NASDAQ:CORZ) growth trajectory, having exited from bankruptcy through pivoting aggressively into Artificial Intelligence infrastructure in January last year. At present, the company is worth $5 billion in market capitalization. While we acknowledge the potential of CORZ as an investment, our conviction lies in the belief that some AI stocks hold greater promise for delivering higher returns and have limited downside risk. If you are looking for an extremely cheap AI stock that is also a major beneficiary of Trump tariffs and onshoring, see our free report on the best short-term AI stock. READ NEXT: 20 Best AI Stocks To Buy Now and 30 Best Stocks to Buy Now According to Billionaires. Disclosure: None. This article is originally published at Insider Monkey. Error in retrieving data Sign in to access your portfolio Error in retrieving data Error in retrieving data Error in retrieving data Error in retrieving data
Yahoo
25 minutes ago
- Yahoo
Defense Department to end satellite data programs used for storm forecasts
June 28 (UPI) -- With the of peak hurricane season looming, forecasters will be without key information starting Monday because the Defense Department said it will no longer provide them with data from the weather satellites. The National Oceanic and Atmospheric Administration published a notice Wednesday about the change. "Due to recent service changes, the Defense Meteorological Satellite Program (DMSP) and Navy's Fleet Numerical Meteorology and Oceanography Center (FNMOC) will discontinue ingest, processing and distribution of all DMSP data no later than June 30, 2025," the notice said. "This service change and termination will be permanent." This change is coming amid cuts in staffing at NOAA, as well as reductions in scientific programs. One unidentified NOAA scientist told The Guardian the changes amount to a "systemic destruction of science." For 40 years, the Pentagon has operated satellites for atmospheric and ocean conditions. There are three now. The satellites gather multiple wavelengths of light, including visible, infrared, microwave, Kim Wood, an atmospheric scientist at the University of Arizona, told Scientific American. Microwaves are used to monitor hurricanes, Wood said, "because the waves are so long they get through the tops of the clouds" and help scientists to understand a storm's inner workings, especially those that occur at night. The U.S. Navy's Fleet Numerical Meteorology and Oceanography Center processes raw data, which is then used by scientists and forecasters for real-time data. The satellites also are used to collect data on sea ice in polar regions. A U.S. Space Force spokesperson said in a statement that the satellites and instruments are functional and that the Department of Defense will continue to use them while access for scientists is cut off. The agency uses data to track conditions for its ships. "It's not an issue of funding cuts," Mark Serreze, the director of the National Snow and Ice Data Center, a federally funded research center in Colorado, told NPR. "There are cybersecurity concerns. That's what we're being told." With the data, hurricane experts can see where the center of a storm forms, and hence figure out the direction where it could be headed, including land. Also, they can see when a new eyewall forms, which helps determine intensity. That was done with Hurricane Erick earlier this month in the Pacific Ocean. The National Hurricane Center, which is overseen by NOAA, doesn't expect less-accurate forecasts. "NOAA's data sources are fully capable of providing a complete suite of cutting-edge data and models that ensure the gold-standard weather forecasting the American people deserve," NOAA communications director Kim Doster told NPR. NOAA and NASA also operate satellites that are used for forecasts. Brian Tang, a hurricane researcher at the University at Albany, told NPR that it is important to have as many data sensors as possible. "I was surprised, given how important it is for forecasting hurricanes and monitoring important features like sea ice," Tang said. "This is data that forecasters use regularly." "We're a bit blind now," said Allison Wing, a hurricane researcher at Florida State University, told The Guardian. "Before these types of satellites were present, there would often be situations where you'd wake up in the morning and have a big surprise about what the hurricane looked like," she said. "Given increases in hurricane intensity and increasing prevalence towards rapid intensification in recent years, it's not a good time to have less information." The hurricane season runs from June 1 to Nov. 30 with five so far named in the Pacific and one so far in the Atlantic.
Yahoo
26 minutes ago
- Yahoo
Sudden loss of key US satellite data could send hurricane forecasting back ‘decades'
A critical US atmospheric data collection program will be halted by Monday, giving weather forecasters just days to prepare, according to a public notice sent this week. Scientists that the Guardian spoke with say the change could set hurricane forecasting back 'decades', just as this year's season ramps up. In a National Oceanic and Atmospheric Administration (Noaa) message sent on Wednesday to its scientists, the agency said that 'due to recent service changes' the Defense Meteorological Satellite Program (DMSP) will 'discontinue ingest, processing and distribution of all DMSP data no later than June 30, 2025'. Due to their unique characteristics and ability to map the entire world twice a day with extremely high resolution, the three DMSP satellites are a primary source of information for scientists to monitor Arctic sea ice and hurricane development. The DMSP partners with Noaa to make weather data collected from the satellites publicly available. Related: Trump plans on 'phasing out' Fema disaster agency after hurricane season The reasons for the changes, and which agency was driving them, were not immediately clear. Noaa said they would not affect the quality of forecasting. However, the Guardian spoke with several scientists inside and outside of the US government whose work depends on the DMSP, and all said there are no other US programs that can form an adequate replacement for its data. 'We're a bit blind now,' said Allison Wing, a hurricane researcher at Florida State University. Wing said the DMSP satellites are the only ones that let scientists see inside the clouds of developing hurricanes, giving them a critical edge in forecasting that now may be jeopardized. 'Before these types of satellites were present, there would often be situations where you'd wake up in the morning and have a big surprise about what the hurricane looked like,' said Wing. 'Given increases in hurricane intensity and increasing prevalence towards rapid intensification in recent years, it's not a good time to have less information.' The satellites also formed a unique source of data for tracking changes to the Arctic and Antarctic, and had been tracking changes to polar sea ice continuously for more than 40 years. 'These are some of the regions that are changing the fastest around the planet,' said Carlos Moffat, an oceanographer at the University of Delaware who had been working on a research project in Antarctica that depended on DMSP data. 'This new announcement about the sea ice data really amounts to blinding ourselves and preventing us from observing these critical systems.' Researchers say the satellites themselves are operating normally and do not appear to have suffered any errors that would physically prevent the data from continuing to be collected and distributed, so the abrupt data halt might have been an intentional decision. Related: Key US weather monitoring offices understaffed as hurricane season starts 'It's pretty shocking,' Moffat said. 'It's hard to imagine what would be the logic of removing access now and in such a sudden manner that it's just impossible to plan for. I certainly don't know of any other previous cases where we're taking away data that is being collected, and we're just removing it from public access.' The loss of DMSP comes as Noaa's weather and climate monitoring services have become critically understaffed this year as Donald Trump's so-called 'department of government efficiency' (Doge) initiative has instilled draconian cuts to federal environmental programs. A current Noaa scientist who wishes to remain anonymous for fear of retaliation said that the action to halt the DMSP, when taken in context with other recent moves by the Trump administration, amounted to 'a systematic destruction of science'. The researcher also confirmed that federal hurricane forecasters were left unprepared for the sudden change with only a few days of notice. 'It's an instant loss of roughly half of our capabilities,' said the scientist. 'You can't expect us to make accurate forecasts and warnings when you take the useful tools away. It frankly is an embarrassment for the government to pursue a course with less data and just pretend everything will be OK.' Scientists said the decision to halt the DMSP will result in immediately degraded hurricane forecasts during what is expected to be an above-average season as well as a gap in monitoring sea ice – just as Arctic sea ice is hitting new record lows. Given increases in hurricane intensity and increasing prevalence towards rapid intensification ... it's not a good time to have less information Allison Wing, hurricane researcher 'This is a huge hit to our forecasting capabilities this season and beyond, especially our ability to predict rapid intensification or estimate the strength of storms in the absence of hurricane hunters,' said Michael Lowry, a meteorologist who has worked at Noaa's National Hurricane Center and with the Federal Emergency Management Agency. 'The permanent discontinuation of data from these satellites is senseless, reckless and puts at risk the lives of tens of millions of Americans living in hurricane alley.' The DMSP dates back to 1963, when the Department of Defense determined a need for high-resolution cloud forecasts to help them plan spy missions. The program, which had been the longest-running weather satellite initiative in the federal government, has since evolved into a critical source of information not just on the inner workings of hurricanes, but also on polar sea ice, wildfires, solar flares and the aurora. In recent years, the DMSP had struggled to maintain consistent funding and priority within the Department of Defense as it transitioned away from its cold war mission. The only other nation with similar satellite capability is Japan, and messages posted earlier in June indicate that scientists had already been considering a switch to the Japanese data in case of a DMSP outage – though that transition will take time. Related: 'Flying blind': Florida weatherman tells viewers Trump cuts will harm forecasts Neither Noaa nor the Department of Defense specified exactly which service changes may have prompted such a critical program to be so abruptly halted. In a statement to the Guardian, Noaa's communications director, Kim Doster, said: 'The DMSP is a single dataset in a robust suite of hurricane forecasting and modeling tools in the National Weather Service portfolio. This routine process of data rotation and replacement would go unnoticed in past administrations, but the media is insistent on criticizing the great work that Noaa and its dedicated scientists perform every day. 'Noaa's data sources are fully capable of providing a complete suite of cutting-edge data and models that ensure the gold-standard weather forecasting the American people deserve.' One Noaa source the Guardian spoke to said the loss of DMSP's high-resolution data could not be replaced by any other existing Noaa tool. A statement from an official at US space force, which is part of the Department of Defense, said: 'The National Oceanic and Atmospheric Administration (Noaa) operates the Defense Meteorological Satellite Program (DMSP) for the DoD on behalf of the US Space Force, who has satellite control authority.' The official went on to say that Noaa receives the data from the US navy's Fleet Numerical Meteorology and Oceanography Center (FNMOC) and added: 'While the Space Force does provide DMSP data and processing software to DoD users, to include the US Navy, questions about the reasons for FNMOC's changes to DMSP data processing should be directed to the Navy. 'Even as FNMOC is making a change on their end, the posture on sharing DMSP data has not changed. Noaa has been making this DMSP data publicly available, and many non-DoD entities use this data that is originally processed by FNMOC. 'DMSP satellites and instruments are still functional. The data provided to FNMOC is just one way the DoD uses DMSP data. DoD users (including the Navy) will continue to receive and operationally use DMSP data sent to weather satellite direct readout terminals across the DoD.' The Guardian is approaching the US navy for comment.
