Air India: How the Boeing Dreamliner crash investigation is unfolding
Less than 40 seconds.That's how long Air India Flight 171 was airborne before it plunged into a densely populated neighbourhood in Ahmedabad in one of India's rarest aviation disasters in recent memory.Investigators now face the grim task of sifting through the wreckage and decoding the cockpit voice and flight data recorders of the Boeing 787 Dreamliner to piece together what went catastrophically wrong in the seconds after take-off. Under international rules set by the UN aviation body ICAO, a preliminary investigation report should be released within 30 days, with the final report ideally completed within 12 months.The London Gatwick-bound aircraft, piloted by Captain Sumeet Sabharwal and co-pilot Clive Kundar, lifted off from the western Indian city of Ahmedabad at 13:39 local time [08:09 GMT] on Thursday, with 242 people and nearly 100 tonnes of fuel on board. Within moments, a mayday call crackled from the cockpit. It would be the last transmission. This was followed by a loss of altitude and a crash engulfed in flames.What could have caused Air India plane to crash in 30 seconds?Captain Kishore Chinta, a former investigator with India's Aircraft Accident Investigation Bureau (AAIB), calls this "the rarest of the rare" crashes - a controlled flight into terrain just 30 seconds after take-off. "To my knowledge, nothing quite like this has ever happened," he told the BBC.Did both engines fail due to bird strikes or fuel contamination? Were the flaps improperly extended, reducing lift on a heavily loaded jet in extreme heat? Was there a maintenance error during engine servicing? Or did an inadvertent crew action cut off fuel to both engines?
Investigators will be probing all these possibilities - and more. Air crash investigations rely on triangulation and elimination - matching physical evidence from the wreckage with recorded aircraft performance data to build a coherent picture of what went wrong.Every scorched cable, damaged turbine blade, airplane maintenance log, and signals and sounds from the flight data and cockpit voice recorders - the so-called "black box" - will be examined. The BBC spoke to accident experts to understand how the investigation will proceed.Critically, the first clues on the ground may come from the wreckage of the two engines, at least three investigators said."You can tell from the damage whether the engines were generating power at impact - turbines fracture differently when spinning at high speed," says Peter Goelz, a former managing director of US's National Transportation Safety Board (NTSB). "That's the first clue to what went wrong." Turbines are crucial rotating components that play a key role in extracting energy to generate thrust."If the engines weren't producing power, investigators have a serious case on their hands - and the focus will shift sharply to the cockpit."What happened in the cockpit will be revealed by the Boeing 787's Enhanced Airborne Flight Recorders (EAFRs) - or the "black boxes" - which, investigators say, will help tell the story. (Indian officials say the recorders have been recovered from the crash site.)These devices capture extensive flight data and cockpit audio - from pilot radio calls to ambient cockpit sounds. Voice recordings come from individual pilot mics, radio transmissions and an area microphone that picks up background noise in the cockpit.Data recorders track with high precision the position of gear and flap levers, thrust settings, engine performance, fuel flow and even fire handle activation.
"If the flight data recorder shows the engines were making full power, then the attention will move to the flaps and slats. If they are found to be extended as needed, then it becomes a very difficult investigation," says Mr Goelz. Flaps and slats increase lift at lower speeds, helping an aircraft take off and land safely by allowing it to fly slower without stalling."If [the trail leads] to a problem in the flight management control system, that would raise serious concerns - not just for Boeing, but for the entire aviation industry."The Boeing 787's flight management control system is a highly automated suite that manages navigation, performance and guidance. It integrates data from a number of sensors to optimise the aircraft's flight path and fuel efficiency.With over 1,100 Boeing 787s flying worldwide since 2011, investigators must determine whether this was a systemic issue that could affect the global fleet - or a one-off failure unique to this flight, experts say. "If it points to a system problem, then the regulatory bodies have to make some tough decisions very quickly," says Mr Goelz.So far, there is no indication of fault on anyone's part. India's civil aviation ministry said on Tuesday that a recent inspection of Air India's Boeing 787 fleet - 24 of 33 aircraft have been checked so far - "did not reveal any major safety concern," adding that the planes and maintenance systems complied with existing standards.Boeing President and CEO Kelly Ortberg said on 12 June: "Boeing will defer to India's Aircraft Accident Investigation Bureau (AAIB) for information on Air India Flight 171, in line with UN ICAO protocol."Decoding of the data at the AAIB lab in Delhi will be led by Indian investigators, with experts from Boeing, engine-maker GE, Air India and Indian regulators. Investigators from the NTSB and UK will also be participating."In my experience, teams can usually determine what happened fairly quickly," Mr Goelz says. "But understanding why it happened can take much longer."The wreckage may yield other clues. "Every part - wire, nut, bolt - will be meticulously collected," says Mr Chinta. Typically, wreckage is moved to a nearby hangar or secure facility, laid out to identify the nose, tail and wingtips, and then pieced together. In this case, depending on what the flight data and voice recorders reveal, a full reconstruction may not be necessary, investigators say.The importance of wreckage varies by accident, say investigators. For Malaysia Airlines flight MH17, shot down over eastern Ukraine in July 2014, it was crucial - reconstruction of the nose revealed clear shrapnel damage from a Russian-made missile.
In the wreckage, investigators will also examine fuel filters, lines, valves and residual fuel to check for contamination - something that's easy to detect or rule out, a crash investigator who preferred to remain unnamed, said. Also, he believed that the refuelling equipment used before departure "has likely been quarantined and already inspected".That's not all. Investigators will gather maintenance and fault history records from the airline and Boeing's ACARS (Aircraft Communications Addressing and Reporting system) which transmits data via radio or satellite to both Boeing and Air India, says Mr Chinta.They will review all flights operated by the aircraft and the crew over recent months, along with the technical log of pilot-reported faults and corrective actions taken before release of aircraft to service.Investigators will also examine pilot licenses, training records, simulator performance and instructor remarks - including how pilots handled scenarios like engine failures in advanced flight simulators. "I reckon Air India would have already provided these records to the investigation team," says Mr Chinta.Investigators will review the service history of all components of the aircraft that were removed and replaced, examining reported defects for any recurring issues - or signs of problems that could have affected this flight."These investigations are extraordinarily complex. They take time, but there will be early indicators of what likely went wrong," says Mr Goelz.A big reason is how far technology has come. "One of the first accidents I investigated in 1994 had a flight data recorder tracking just four parameters," he says."Today's recorders capture hundreds - if not thousands - every second. That alone has transformed the way we investigate crashes."Follow BBC News India on Instagram, YouTube, Twitter and Facebook.
Hashtags
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
The Guardian
29 minutes ago
- The Guardian
Maunika Gowardhan's recipes for Indian pea curries
The sweetness of fresh green peas works so well with Indian curries and spices, and June is the month to make the most of them, because they're now at their peak. Even the empty pods have so much flavour and sweetness, which makes them perfect for a quick salad on the side (toss thinly sliced raw, blanched or even griddled pods with chopped tomato, sliced onion and coriander, drizzle over some fresh mint raita and sprinkle with chaat masala). Blanch the fresh peas without any seasoning before you make the curry, then add them to the simmering gravy near the end. You can swap them for frozen peas, too, if you like. AKA Maharashtrian ambat vatana rassa, this is a family recipe from our home in Mumbai. Traditionally, we use kokum, or dried wild mangosteen, to impart a sour, tangy flavour and a hint of colour, but you could use tamarind instead – the curry should be tart and tangy, so add to taste and according to the quality of your tamarind paste (the one I use is a pretty weak one, so I needed two tablespoons). We usually serve this with a buttery spiced ghee rice. Prep 10 minSoak 20 min Cook20 minServes 4 300g podded fresh green peas, or frozen peas, defrosted 2 tbsp vegetable oil 12 fresh curry leaves½ tsp ground turmeric 350g boiled potatoes, cut into chunks5 kokum petals, soaked in 50ml warm water for 20 min, or 2 tbsp tamarind paste, or to taste(see recipe introduction)Salt, to tasteCooked rice, to serve For the coconut paste3 dried kashmiri red chillies 1 tbsp coriander seeds 1 tsp black peppercorns 120g grated fresh coconut Cook the fresh green peas in boiling water for two to three minutes, then drain and refresh; if you're using frozen peas, there's no need to cook them first, because they'll get cooked directly in the curry sauce. Now for the paste. Soak the red chillies in 100ml warm water for 15 minutes. Meanwhile, in a blender, grind the coriander seeds and peppercorns to a rough powder. Add the soaked chillies, their soaking liquid and the coconut to the blender and blitz to a smooth paste. Put the oil in a large, heavy-based saucepan on a medium heat. When it's hot, add the curry leaves and coconut paste, and fry, stirring, for two minutes. Stir in the ground turmeric, fry for a minute, then pour in 250ml cold water, bring to a simmer and cook for a minute. Turn down the heat, add the peas, the cooked potatoes, the kokum and its soaking liquid. Season with salt to taste, simmer for a final two minutes, then serve warm with rice. Or matar ka nimona, which hails from Benares in northern Uttar Pradesh. This soupy curry is usually served with rice or breads. Prep 15 minCook 45 minServes 4 350g podded fresh green peas, or frozen peas, defrosted3 garlic cloves, peeled5cm piece fresh ginger, peeled1 green birds' eye chilli 5 tbsp ghee 200g potatoes, peeled and diced1 tsp cumin seeds 2 bay leaves 100g finely chopped white onion 1 tbsp ground coriander 1 tsp ground turmeric 120g ripe tomatoes, finely choppedSalt, to taste½ tsp garam masala, to finishA little fresh coriander, roughly chopped, to garnishRoti or rice, to serve Cook the fresh green peas, if using, in boiling water for two to three minutes, then drain. Put half the cooked peas (or half the defrosted frozen peas) in a blender, pulse to a coarse paste, then scrape into a bowl and add the remaining whole peas. Tip the garlic, ginger, green chilli and a splash of water into the blender, then blitz to a smooth paste. Put two tablespoons of the ghee in a large saucepan on a medium heat. Add the potatoes and fry, stirring often so they don't catch and burn, for 12 to 14 minutes, until evenly coloured all over and cooked through. Drain the potatoes, then put them on a large plate or tray lined with kitchen paper. Melt the remaining three tablespoons of ghee in the same pan on a medium heat, then add the cumin seeds and bay leaves. When they start to sizzle, add the onion and fry, stirring often, for eight or nine minutes, until it starts to soften without taking on any colour. Add the garlic, ginger and chilli paste, fry for a minute, then stir in the ground coriander and turmeric. Add the chopped tomatoes, then fry, stirring, for six minutes, until they soften and the sauce thickens. Add all the green peas, stir for a minute more, then add the fried potatoes and 200ml water. Bring to a simmer, cook for a minute or so (the pea paste will help thicken the sauce), then add salt to taste. Stir in the garam masala, then turn off the heat and leave to stand for a couple of minutes. Garnish with coriander and serve with roti or rice. Maunika Gowardhan is a cook and food writer. Her most recent book, Tandoori Home Cooking: Over 70 Classic Indian Tandoori Recipes to Cook at Home, is published by Hardie Grant at £25. To order a copy for £22.50, go to
Reuters
30 minutes ago
- Reuters
What you need to know about the Air India Boeing Dreamliner crash
June 18 (Reuters) - The crash of an Air India Boeing (BA.N), opens new tab 787 Dreamliner seconds after takeoff from Ahmedabad city, killing all but one of the 242 people on board, is the world's worst aviation disaster in a decade. At least 30 people were also killed on the ground as the airliner crashed into a medical college hostel near the airport. The crash poses a fresh challenge for Air India, which has long sought to become a "world-class airline", and Boeing, which is working to restore public trust after a series of safety and production crises. * A 59-second CCTV video clip, one of the strongest pieces of visual evidence, showed the takeoff and the crash. The descent of the plane starts roughly 17 seconds after takeoff. There is no fire visible around the engine or elsewhere when the plane appears to start going down. * There were 169 Indians, 53 Britons, 7 Portuguese, and one Canadian among the passengers on board. Twelve crew members were also on the plane. * The only survivor was Viswashkumar Ramesh, 40, who was in seat 11A, near the emergency exit. * Dozens of anxious family members are waiting to collect bodies of loved ones as doctors work to gather dental samples and do DNA profiling to identify bodies badly charred. * Air India and the Indian government are looking at issues linked to engine thrust, flaps, and why the landing gear remained open. The black boxes, crucial to the crash probe, have been recovered. * India's aviation safety watchdog has asked Air India for the training records of the pilots and dispatchers, while asking flying schools to conduct training compliance checks. * Officials from the U.S. National Transportation Safety Board and U.S. Federal Aviation Administration officials, as well as Boeing and GE, have surveyed the crash site. * An inspection of Air India's 787 fleet did not reveal any major issues, but the Indian aviation watchdog raised concerns about recent maintenance-related issues reported by the airline and advised the carrier to "strictly adhere to regulations". * The plane hit a college hostel building. When Reuters visited, some steel tumblers and plates containing food lay on the few tables that were left intact. Wheels and other parts of the aircraft were embedded in the walls. * Ravi Thakor, a cook at the college hostel, and his wife have been praying for a 'second miracle' - just like the survival of the sole passenger - as he searches for his two-year-old daughter, whom he had rocked to sleep before stepping out 30 minutes before the crash to deliver lunch boxes. * Lawrence Christian, a 30-year-old working in Britain, had flown to India to bury his father, but just two weeks later, his family will have to bury him. His grandmother grieved the loss of "light of our home." * Boeing Commercial Airplanes' head Stephanie Pope visited India and met Air India Chair N. Chandrasekaran at the airline's headquarters. * Chandrasekaran also held a town hall meeting with 700 staff saying the Tata Group-owned airline should use the crash as a catalyst to build a safer airline. * In another incident, an Air India Boeing 787-8 Dreamliner plane bound for New Delhi returned to its origin of Hong Kong after takeoff on June 16 following a technical issue.
The Guardian
3 hours ago
- The Guardian
The miracle of seat 11A and the tragedy of an Air India crash
Air India flight AI171 took off from Ahmedabad airport on the afternoon of 12 June with 242 people on board. Less than a minute later, it had crashed into a medical college about 1km away. Including those on the ground, at least 270 people were killed. But one passenger miraculously survived. Vishwash Kumar Ramesh, a British national sat in seat 11A, was able to walk away from the scene – though, as he found out soon after, his brother had died on board. The aviation journalist Jeff Wise explains what investigators will be looking at to determine the cause the crash – from the plane's landing gear, to its wing flaps and possible pilot error. Helen Pidd asks how it was possible that Ramesh was able to escape with his life.
