Delaware City Refinery continues toxic chemical release. Here's what we know
The Delaware City Refinery has been continuously releasing more than permitted amounts of toxic sulfur dioxide into the air for a week now, yet there are still more questions than answers.
Here's what we know.
The Delaware City Refinery is located on 5,000 acres just north of Delaware City, along the Delaware River, with a New Castle address.
It's owned by PBF Energy, "one of the largest independent petroleum refiners and suppliers of unbranded transportation fuels, heating oil, petrochemical feedstocks, lubricants and other petroleum products in the United States," according to the company's website.
The Delaware City Refinery is "one of the largest and most complex refineries on the East Coast," the website says, and can process up to 180,000 barrels of oil per day.
Historically, the Delaware City Refinery has been the state's biggest polluter, frequently cited for air pollution violations. In October 2024, the Delaware Department of Natural Resources and Environmental Control found that the refinery had deviated from its permit standards nine times between September 2022 and August 2023 and fined the refinery $75,000.
More than 86,000 people live within a 5-mile radius of the refinery, over half of whom are people of color and 20% of whom are lower-income, according to EPA data. Due to concerns with diversity, equity and inclusion, earlier this year, the EPA canceled a $500,000 grant that would have allowed the nonprofit Clean Air Council to monitor air pollution in the area of the refinery.
Sulfur dioxide is a gas composed of sulfur and oxygen. It forms when fuel such as oil, like at the Delaware City Refinery, is burned.
Background: Air monitor shows pollutant from Delaware City Refinery in acceptable range: DNREC
Sulfur dioxide can make it hard to breathe and harm the human respiratory system, according to the Environmental Protection Agency. It can also harm animals and plants.
Delaware Environmental Release Notification System, which reports on the Delaware City Refinery releases, says sulfur dioxide "may cause death or permanent injury after very short exposure to small quantities."
Signs of acute sulfur dioxide exposure include symptoms such as coughing, shortness of breath, wheezing, fatigue, chest discomfort, nausea, vomiting, stomach pain and cyanosis, the reports say. People with asthma, subnormal pulmonary functions or cardiovascular disease are at a greater risk than others.
The fossil fuel industry is the largest contributor of sulfur dioxide into the atmosphere, according to the EPA. Refineries like the Delaware City Refinery are typically allowed to emit certain amounts of pollutants into the air and water through state and federal permits.
The release of sulfur dioxide is ongoing and will continue "until the repairs are made," a May 31 Delaware Environmental Release Notification System report says.
The refinery's air quality permit doesn't appear to be available online, so how much sulfur dioxide the company is normally permitted to release is unknown.
According to reports publicly posted on the Delaware Environmental Release Notification System website, the following amounts of sulfur dioxide were released by the Delaware City Refinery since May 25.
11:30 p.m., May 25: "over 100 pounds"
12:01 a.m., May 26: "greater than 500 pounds"
9:55 a.m., May 28: 500 pounds per hour
11:16 a.m., May 29: 1,450 pounds per hour
10:05 a.m., May 30: 1,450 pounds per hour
9 p.m., May 31: "greater than 500 pounds"
The Delaware Department of Natural Resources and Environmental Control issued a news release related to these incidents on May 31. It noted information from an air monitoring station east of the refinery on Route 9, but didn't state the direction in which the wind was blowing at the time the information was recorded.
Related: Delaware City Refinery 'deviated' from its permit 7 times in 2024 with no violations
The "health standard" for sulfur dioxide, according to the news release, is 75 parts per billion. The highest hourly measurement during "this incident" was 25 parts per billion for 6 a.m. on May 31, the release said. The highest-recorded daily average sulfur dioxide level was 2.5 parts per billion on May 26. When the news release was issued on May 31, the average was 7.33 parts per billion.
Since the news release was issued, more data has become available on the department's Air Quality Monitoring Network website. It shows a new highest hourly measurement of 29 parts per billion at midnight on June 1.
Some DERNS reports cite "a boiler failure."
DNREC and PBF representatives did not immediately respond to questions.
DERNS sends out notifications of chemical releases, but only to people who have signed up.
DNREC spokesman Michael Globetti said concerning a past chemical release that DERNS is "not intended to be an emergency notification system, but rather a system to allow citizens to stay informed."
The Department of Emergency Management Agency has sent out notifications of past chemical releases, but Director A.J. Schall said they haven't sent out any releases related to the current refinery incident.
It's unknown. DNREC and PDF representatives did not immediately respond to questions.
Molly McVety contributed to this story. Shannon Marvel McNaught reports on southern Delaware and beyond. Reach her at smcnaught@gannett.com or on Facebook.
This article originally appeared on Delaware News Journal: Delaware City Refinery continues to release toxic chemical into air
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
San Francisco Chronicle
2 hours ago
- San Francisco Chronicle
Confusion on sensor plane's abilities delayed response in Ohio train derailment, report says
A specialized plane equipped with advanced sensors that the government deploys to chemical disasters could have helped authorities avoid needlessly blowing open five rail tank cars and burning their toxic contents after the disastrous 2023 East Palestine train derailment, a new report says. The report released Tuesday found the single-engine Cessna wasn't called into action until the night before the rail cars filled with vinyl chloride were blown open because officials with the Environmental Protection Agency on the ground didn't fully understand the aircraft's sophisticated capabilities. The report by the EPA's Inspector General said the agency's on-scene coordinator mistakenly thought the so-called ASPECT plane could only measure 20- to 30-degree differences in temperature. In reality, the report noted, the sensors can measure slight temperature differences of less than 1 degree. That information could have helped first responders avoid the key mistake the National Transportation Safety Board identified of blowing open the tank cars filled with the toxic plastic ingredient. The on-scene coordinator's 'limited awareness or use of the full range of ASPECT capabilities could negatively impact emergency response decision-making,' the report said. The towering plume of black smoke The explosion and fire generated a massive plume of black smoke over East Palestine that billowed eastward over the nearby Ohio-Pennsylvania border three days after the derailment. State and local officials in charge of the response feared those tank cars would explode even though the limited temperature information they had showed the cars were starting to cool off. The National Transportation Safety Board had previously faulted the Norfolk Southern railroad for not sharing the opinion of the chemical maker that the vinyl chloride wasn't going to explode with decisionmakers. Norfolk Southern has said OxyVinyls officials offered conflicting information that left the railroad's experts worried about a dangerous chemical reaction. Much of the small town of East Palestine had to be evacuated for days because of the toxic chemical fire. Many residents still complain of lingering health symptoms, fearful of potential long-term health consequences. The EPA has maintained that dangerous levels of chemicals were never found after the evacuation order was lifted five days after the Feb. 3, 2023, derailment. Some have questioned whether the agency did enough to detect the chemicals in the aftermath and doctors are still trying to determine what prolonged exposure to low levels of the chemicals might mean. Recently released records show officials with the Federal Emergency Management Administration have acknowledged residents' fears that cancer clusters could develop years from now in area residents despite the EPA's assurances. Robert Kroutil, the man who wrote the software and helped interpret the data from the plane's advanced radiological and infrared sensors, has said having accurate temperature data from the plane could have helped avoid the vent-and-burn operation. 'The report noted that EPA officials believe that the on-ground monitoring equipment provided superior detection capabilities, which is incorrect,' Kroutil said. "This demonstrates EPA's complete lack of understanding of the ASPECT technology and how it works to protect chemically impacted sites.' The East Palestine derailment was the worst rail disaster in a decade. It prompted a national reckoning with rail safety and calls for reform — although proposals for new industry rules stalled in Congress. The railroad's contractors who led the response to the derailment told the NTSB they had difficulty getting accurate temperature readings on the cars because the fire surrounding them made it especially dangerous. Kroutil's concerns prompted the IG investigation. The EPA said in its official response to the report that it has developed a detailed fact sheet and plans to train its emergency responders about the plane's capabilities and when it should be deployed over the next year. But the agency didn't immediately respond Tuesday to questions about the delayed response in East Palestine. Lingering questions about the flights The Government Accountability Project watchdog group that helped Kroutil document his concerns questioned why the Inspector General didn't look into other aspects like Kroutil's concerns that the plane's sensors were intentionally shut off over the creeks around East Palestine and that the final report on the flights was changed to overlook the incomplete data that was generated in just two flights before the plane was sent home. GAP's Senior Environmental Officer Lesley Pacey said 'the investigation's scope was too narrow, failing to address the most serious allegations.' The EPA didn't even call for the sensor plane until two nights after the derailment when officials were already contemplating the vent-and-burn operation. The plane took off from its Texas base within a half hour of getting the call, but it didn't make a pass over the derailment as it flew into the area that night, and then weather conditions kept it from flying during the controversial burn operation the next day. It didn't gather any data until the following day after most of the chemicals had already been distributed by the wind. The Inspector General said the emails and documents it reviewed showed that officials followed existing practices on deploying the plane, but those procedures lacked the clarity needed to help them decide when to deploy the plane.
Yahoo
2 hours ago
- Yahoo
Confusion on sensor plane's abilities delayed response in Ohio train derailment, report says
A specialized plane equipped with advanced sensors that the government deploys to chemical disasters could have helped authorities avoid needlessly blowing open five rail tank cars and burning their toxic contents after the disastrous 2023 East Palestine train derailment, a new report says. The report released Tuesday found the single-engine Cessna wasn't called into action until the night before the rail cars filled with vinyl chloride were blown open because officials with the Environmental Protection Agency on the ground didn't fully understand the aircraft's sophisticated capabilities. The report by the EPA's Inspector General said the agency's on-scene coordinator mistakenly thought the so-called ASPECT plane could only measure 20- to 30-degree differences in temperature. In reality, the report noted, the sensors can measure slight temperature differences of less than 1 degree. That information could have helped first responders avoid the key mistake the National Transportation Safety Board identified of blowing open the tank cars filled with the toxic plastic ingredient. The on-scene coordinator's 'limited awareness or use of the full range of ASPECT capabilities could negatively impact emergency response decision-making,' the report said. The towering plume of black smoke The explosion and fire generated a massive plume of black smoke over East Palestine that billowed eastward over the nearby Ohio-Pennsylvania border three days after the derailment. State and local officials in charge of the response feared those tank cars would explode even though the limited temperature information they had showed the cars were starting to cool off. The National Transportation Safety Board had previously faulted the Norfolk Southern railroad for not sharing the opinion of the chemical maker that the vinyl chloride wasn't going to explode with decisionmakers. Norfolk Southern has said OxyVinyls officials offered conflicting information that left the railroad's experts worried about a dangerous chemical reaction. Much of the small town of East Palestine had to be evacuated for days because of the toxic chemical fire. Many residents still complain of lingering health symptoms, fearful of potential long-term health consequences. The EPA has maintained that dangerous levels of chemicals were never found after the evacuation order was lifted five days after the Feb. 3, 2023, derailment. Some have questioned whether the agency did enough to detect the chemicals in the aftermath and doctors are still trying to determine what prolonged exposure to low levels of the chemicals might mean. Recently released records show officials with the Federal Emergency Management Administration have acknowledged residents' fears that cancer clusters could develop years from now in area residents despite the EPA's assurances. Robert Kroutil, the man who wrote the software and helped interpret the data from the plane's advanced radiological and infrared sensors, has said having accurate temperature data from the plane could have helped avoid the vent-and-burn operation. 'The report noted that EPA officials believe that the on-ground monitoring equipment provided superior detection capabilities, which is incorrect,' Kroutil said. "This demonstrates EPA's complete lack of understanding of the ASPECT technology and how it works to protect chemically impacted sites.' EPA updates its policies The East Palestine derailment was the worst rail disaster in a decade. It prompted a national reckoning with rail safety and calls for reform — although proposals for new industry rules stalled in Congress. The railroad's contractors who led the response to the derailment told the NTSB they had difficulty getting accurate temperature readings on the cars because the fire surrounding them made it especially dangerous. Kroutil's concerns prompted the IG investigation. The EPA said in its official response to the report that it has developed a detailed fact sheet and plans to train its emergency responders about the plane's capabilities and when it should be deployed over the next year. But the agency didn't immediately respond Tuesday to questions about the delayed response in East Palestine. Lingering questions about the flights The Government Accountability Project watchdog group that helped Kroutil document his concerns questioned why the Inspector General didn't look into other aspects like Kroutil's concerns that the plane's sensors were intentionally shut off over the creeks around East Palestine and that the final report on the flights was changed to overlook the incomplete data that was generated in just two flights before the plane was sent home. GAP's Senior Environmental Officer Lesley Pacey said 'the investigation's scope was too narrow, failing to address the most serious allegations.' The EPA didn't even call for the sensor plane until two nights after the derailment when officials were already contemplating the vent-and-burn operation. The plane took off from its Texas base within a half hour of getting the call, but it didn't make a pass over the derailment as it flew into the area that night, and then weather conditions kept it from flying during the controversial burn operation the next day. It didn't gather any data until the following day after most of the chemicals had already been distributed by the wind. The Inspector General said the emails and documents it reviewed showed that officials followed existing practices on deploying the plane, but those procedures lacked the clarity needed to help them decide when to deploy the plane.
Yahoo
2 hours ago
- Yahoo
Confusion on sensor plane's abilities delayed response in Ohio train derailment, report says
A specialized plane equipped with advanced sensors that the government deploys to chemical disasters could have helped authorities avoid needlessly blowing open five rail tank cars and burning their toxic contents after the disastrous 2023 East Palestine train derailment, a new report says. The report released Tuesday found the single-engine Cessna wasn't called into action until the night before the rail cars filled with vinyl chloride were blown open because officials with the Environmental Protection Agency on the ground didn't fully understand the plane's sophisticated capabilities. The report by the EPA's Inspector General said the agency's on-scene coordinator mistakenly thought the so-called ASPECT plane could only measure 20- to 30-degree differences in temperature. In reality, the report noted, the sensors can measure slight temperature differences of less than 1 degree. That information could have helped first responders avoid the key mistake the National Transportation Safety Board identified of blowing open the tank cars filled with the toxic plastic ingredient. The on-scene coordinator's 'limited awareness or use of the full range of ASPECT capabilities could negatively impact emergency response decision-making,' the report said. The towering plume of black smoke The explosion and fire generated a massive plume of black smoke over East Palestine that billowed eastward over the nearby Ohio-Pennsylvania border three days after the derailment. State and local officials in charge of the response feared those tank cars would explode even though the limited temperature information they had showed the cars were starting to cool off. The National Transportation Safety Board had previously faulted the Norfolk Southern railroad for not sharing the opinion of the chemical maker that the vinyl chloride wasn't going to explode with decisionmakers. Norfolk Southern has said OxyVinyls officials offered conflicting information that left the railroad's experts worried about a dangerous chemical reaction. Much of the small town of East Palestine had to be evacuated for days because of the toxic chemical fire. Many residents still complain of lingering health symptoms, fearful of potential long-term health consequences. The EPA has maintained that dangerous levels of chemicals were never found after the evacuation order was lifted five days after the Feb. 3, 2023, derailment. Some have questioned whether the agency did enough to detect the chemicals in the aftermath and doctors are still trying to determine what prolonged exposure to low levels of the chemicals might mean. Recently released records show officials with the Federal Emergency Management Administration have acknowledged residents' fears that cancer clusters could develop years from now in local residents despite the EPA's assurances. Robert Kroutil, the man who wrote the software and helped interpret the data from the plane's advanced radiological and infrared sensors, has said having accurate temperature data from the plane could have helped avoid the vent-and-burn operation. 'The report noted that EPA officials believe that the on-ground monitoring equipment provided superior detection capabilities, which is incorrect,' Kroutil said. "This demonstrates EPA's complete lack of understanding of the ASPECT technology and how it works to protect chemically impacted sites.' EPA updates its policies The East Palestine derailment was the worst rail disaster in a decade. It prompted a national reckoning with rail safety and calls for reform — although proposals for new industry rules stalled in Congress. The railroad's contractors who led the response to the derailment told the NTSB they had difficulty getting accurate temperature readings on the cars because the fire surrounding them made it especially dangerous. Kroutil's concerns prompted the IG investigation. The EPA said in its official response to the report that it has developed a detailed fact sheet and plans to train its emergency responders about the plane's capabilities and when it should be deployed over the next year. But the agency didn't immediately respond Tuesday to questions about the delayed response in East Palestine. Lingering questions about the flights The Government Accountability Project watchdog group that helped Kroutil document his concerns questioned why the Inspector General didn't look into other aspects like Kroutil's concerns that the plane's sensors were intentionally shut off over the creeks around East Palestine and that the final report on the flights was changed to overlook the incomplete data that was generated in just two flights before the plane was sent home. GAP's Senior Environmental Officer Lesley Pacey said 'the investigation's scope was too narrow, failing to address the most serious allegations.' The EPA didn't even call for the sensor plane until two nights after the derailment when officials were already contemplating the vent-and-burn operation. The plane took off from its Texas base within a half hour of getting the call, but it didn't make a pass over the derailment as it flew into the area that night, and then weather conditions kept it from flying during the controversial burn operation the next day. It didn't gather any data until the following day after most of the chemicals had already been distributed by the wind. The Inspector General said the emails and documents it reviewed showed that officials followed existing practices on deploying the plane, but those procedures lacked the clarity needed to help them decide when to deploy the plane. Josh Funk, The Associated Press Error in retrieving data Sign in to access your portfolio Error in retrieving data Error in retrieving data Error in retrieving data Error in retrieving data
