Nissan's Oddball Car Under Scrutiny After Airbag Injures Driver
The NHTSA is now investigating an event where the driver of a 2009 Nissan Cube was injured when struck by an airbag module, which incorrectly detached from the steering wheel in what was a single-vehicle crash. Although only one incident was reported, the issue is serious enough for the Office of Defects Investigation (ODI) to look into the matter in more detail.
Airbags manufactured by Takata have been subject to a recall that affected hundreds of thousands of vehicles from various brands, many of them produced in the 2000s and 2010s. So, it should perhaps come as little surprise that the 2009 Nissan Cube involved in this latest incident is fitted with Takata PSDI-X inflators.
Nissan and New Leaf LLC (previously known as Takata) have determined that the rupture was found at the weld point between the inflator cap and inflator housing. After striking the driver and causing injuries that required medical attention, the airbag module ended up in the Cube's back seat. The airbag cushion and inflator were still attached to the module housing.
The Cube's issue could be separate from the wider Takata recall, as the NHTSA stated the Cube's airbag failure "appears to be inconsistent with known ruptures attributed to propellant degradation."
The ODI report mentions the 2009 Cube only, but that already means 28,388 models could be affected. As of this writing, no recall has been issued, as only a completed investigation can determine whether a recall is necessary.
The 2009 model year was the first of the third-gen Cube, but it was also the first Cube to be exported to North America. It is one of Nissan's most unusual designs, and it's still a bizarre sight on roads today.
Hopefully, the ODI determines that this scary airbag failure is an isolated incident and not a flaw that could affect all Cubes.
Copyright 2025 The Arena Group, Inc. All Rights Reserved.
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
The Hill
an hour ago
- The Hill
Kia issues recall on more than 300K vehicles over loose parts
Kia has issued two recalls within a week for more than 300,000 of its vehicles due to loose parts. According to two separate notices from the National Highway Traffic Safety Administration (NHTSA), the recall affects 201,149 2023 to 2025 Telluride models over faulty door belt moldings and 100,063 2023 to 2025 K5 models over window trim detachment issues. The Telluride models may experience loosening and eventual detachment of their door belt molding trims, which is the long, narrow strip located along the top edge of the vehicle's door where the glass window meets the metal frame of the door. K5 models may also face the same issue with their C-pillar garnish face plates, which are the decorative panels located near the left and right rear windows. In an additional notice, Kia said the piece may loosen and fall off due to a supplier quality issue. The loose parts could be a hazard for other drivers and cause crashes, the NHTSA said in the notices. The NHTSA said Kia owners can bring their vehicles to a Kia dealership for a free inspection and replacement of the affected parts. Notification letters will be sent to vehicle owners on Sept. 26.
Car and Driver
10 hours ago
- Car and Driver
Ford Recalling 312,000 Trucks, SUVs with Brake Booster Issue
Ford is recalling another 312,120 vehicles, this time over an issue with the electronic brake booster. The recall population is split among 2025 Ford F-150, Expedition, Bronco, Ranger, and 2025 Lincoln Navigator models, with the majority—217,969—being F-150 pickups. In affected models, the electronic brake booster model can enter a faulted state while driving, creating a total loss of brake boost. Ford's year of recalls continues, with the company issuing yet another, this time for 312,120 vehicles over an issue with the electronic brake booster. The recall population is limited to 2025 models and extends to certain Ford F-150, Expedition, Bronco, and Ranger models, along with the Lincoln Navigator. Ford According to documents associated with the recall, the issue stems from the electronic brake booster (EBB) module, which can shut off either during normal driving or while a driver-assist system (ADAS) is in use. Once in this faulted state, the car won't have any brake boost until the EBB module is reset along with the car's ignition cycle. The documents confirm that as of mid-July, Ford was aware of 37 warranty claims associated with the brake boost issue. Ford is also aware of one alleged low-speed crash related to the issue. No injuries or fires have been connected to the fault, according to NHTSA documents. Lincoln The documents show that the issue arises because the EBB module is susceptible to "normal but infrequent voltage disturbances." A momentary drop in voltage and a subsequent surge can result in a spike that causes the EBB motor to power off. If the brake boost is lost, the ABS, electronic stability control, and brake cluster warning lights will illuminate on the dash alongside warning messages. The loss in boost will also likely cause a change in brake pedal feel and increased pedal travel. The remedy for the issue is a simple software update for the EBB module. Ford expects to begin rolling out over-the-air updates sometime in August, though owners will also have the choice to bring their car to a local dealership for the install. Ford will begin notifying dealers of the crash on August 11, with owner notification letters scheduled to be sent on August 25. Owners concerned that their vehicle may be involved can check on the NHTSA recalls website now. Jack Fitzgerald Associate News Editor Jack Fitzgerald's love for cars stems from his as yet unshakable addiction to Formula 1. After a brief stint as a detailer for a local dealership group in college, he knew he needed a more permanent way to drive all the new cars he couldn't afford and decided to pursue a career in auto writing. By hounding his college professors at the University of Wisconsin-Milwaukee, he was able to travel Wisconsin seeking out stories in the auto world before landing his dream job at Car and Driver. His new goal is to delay the inevitable demise of his 2010 Volkswagen Golf. Read full bio
Motor 1
a day ago
- Motor 1
Recalls Are Good, Actually—Until They Mean a Bigger Problem
It's impossible for a car to be perfect right out of the box. Even some of the best-built vehicles on sale today are subject to recalls. The term 'recall' tends to carry a negative connotation, as it identifies a fault that, for passenger cars, means a legitimate safety risk. But it shouldn't. Lately, it feels like there have been a lot of recalls. Does that mean cars are getting less reliable? Or less safe? Or does it mean manufacturers are stepping up their accountability, tackling issues they wouldn't have before? Simple questions with complicated answers. Have There Been More Recalls Lately? Photo by: NHTSA The short answer is yes. Last year, the National Highway Traffic Safety Administration (NHTSA) released a swath of data on recalls from 2003 to 2023, showing a general upward trend in both the number of recalls and the number of vehicles recalled. Last year was a bit of an outlier, though. In 2024, automakers issued just 445 recalls, encompassing around 29 million vehicles—a drop in both metrics versus 2023. This year is also trending downward, at least in the number of vehicle recalls. Automakers have recalled just over 10.7 million vehicles through the first half of 2025, according to BizzyCar , a recall-focused service management system for dealerships. The number of recalls issued in 2025 is up through the first two quarters, though, with 229 campaigns issued. That's thanks mostly to Ford, which has issued 88 of those recalls alone, or around 36 percent. Ford products represent just over 40 percent of all vehicles recalled in 2025 so far. But why have there been more recalls? There are a host of reasons why the number of recalls and the amount of vehicles recalled have increased over the past 22 years. While the number of new cars sold in the US each year usually hovers between 14 and 17 million vehicles, the cars themselves have grown significantly in complexity. Your average passenger car is far more complex than it was 20 years ago. And because cars are more complex, there's more potential for things to go wrong. Active safety systems, adaptive suspensions, brake & steer by wire, multi-screen infotainment systems, hybrid drivetrains—these are just a few of the reasons why your car might be back in the shop shortly after it leaves the lot. Then there's the ever-increasing complexity of the automotive sector's global supply chain. As environmental disposal service Valicor points out, even a small issue with a non-critical component can trigger a large-scale recall across multiple continents and different manufacturers. Recalls have also increased due to customer expectations. Back in the 1980s, the average buyer likely expected their car to break down more often than the average buyer in 2025. Nowadays, people expect their new car to work 100 percent of the time, complexity be damned. So even if something small goes wrong, manufacturers are held to a higher standard, pushing them to issue recalls they may not have issued 30 years ago. Similarly, regulatory bodies are expecting more than ever from manufacturers. Oversight is as stringent as it's ever been, with the NHTSA closely monitoring incidents and complaints from buyers in order to recognize patterns and hold carmakers accountable. Why More Recalls Are a Good Thing When the average person hears the words 'car recall,' a few moments probably come to mind. Ford's Pinto fire fiasco, Takata's massive airbag debacle, GM's ignition-switch problem, or Volkswagen's Dieselgate scandal, just to name a few. All of those incidents generated a ton of bad press for their respective brands. While GM has mostly escaped with its reputation unscathed, the name Takata will forever be associated with shrapnel-loaded airbags. Volkswagen, meanwhile, is still dealing with the fallout from Dieselgate 10 years later. The first Ford Pinto recall happened nearly 50 years ago. And here we are, still talking about it. The point is, huge, headline-grabbing recalls are bad for business. They erode trust with consumers and tarnish brand image. Having witnessed all of these controversies and the resulting negative impact on their bottom lines, manufacturers across the board now take a more proactive approach to recalls and overall quality. Still, back to my original point, no car is perfect from the get-go. There will always be issues that need fixing. But instead of waiting for problems to fester and grow into gigantic, unmanageable messes—like the issues mentioned above—carmakers have gone in the opposite direction, issuing more recalls than ever to cover their bases. So while automakers recall more cars, it's usually for less dramatic reasons, and in smaller numbers. Tesla, weirdly, is the best example for this. The electric carmaker recalled a staggering 5.1 million vehicles in 2024— the most of any automaker in the US . But a majority of those 'recalls' were solved simply by issuing software updates over the air, without the owner having to drive to a service center (or even leave their garage). Stomping out problems before they become destructive is great for brand reputation, but it's also good news for the end user. Because brands are holding themselves more accountable, buyers end up with a better product. And if something does go wrong, it's more likely the issue will be addressed quickly and properly, before it gets any worse. Recalls Can Still Point to Bigger Issues Car recalls carry far more reach than huge safety or emissions concerns—especially now. Recalls can mean anything from a do-not-drive order due to a leaking brake system to a simple software update. Tesla's huge recall numbers are proof of that. But recalls can still signal a bigger issue, even if the campaigns themselves don't point to one specific problem. Just look at Ford. In 2023, it was among the most recalled brands in the country, with 54 recalls potentially affecting over 5.6 million vehicles. The company didn't fare much better in 2024, recalling 4.7 million cars across 67 different campaigns. Things are getting even worse for the American automaker in 2025. Ford has issued an incredible 94 recalls in 2025 as of this writing, potentially affecting 6.35 million vehicles. That means it's on track to double the number of cars recalled by the end of the year. It's also a record for the most recalls ever issued by a manufacturer in a single year—and there's still six months to go in 2025. There's no one reason for the huge jump in recall numbers—the data above highlights numerous sources, ranging from electrical problems, backup camera faults, powertrain issues, and more. The sheer number of vehicles being affected is, then, indicative of a persistent quality-control issue at Ford. The company is aware of this, of course. 'I think we all have regrets and that's a big one for me,' CEO Jim Farley said last year , highlighting his mistake not to focus on revamping the company's development cycle to improve quality. "It needed a much more fundamental reset than I had realized." Farley has since promised big gains in quality for Ford come 2025, though obviously, those gains haven't materialized. A swell of recalls doesn't just hurt your customers. It costs money, too. Over the last three years, Ford's given up millions in profit to cover warranty and recall repairs. The brand's 90th recall , a fix for a fuel injector problem on Bronco Sports and Escapes, is estimated to cost the company over half a billion dollars, according to Reuters. Nine-figure mistakes like this aren't sustainable. Our advice? Look to rival Volkswagen. In 2022, it was the second-most recalled brand in the country, with over 1 million vehicles recalled. The next year, it had recalled just 332,000 cars, dropping all the way to 18th place. "Volkswagen Group of America has been working diligently to improve the quality of its vehicles, which in turn reduces the potential for recalls,' the company told Motor1 back in 2023. 'Recently, quality problems have been reduced significantly, warranty claims are at a historical low and our regional Quality Testing and Validation program is showing positive results." The lesson here, then, is not to fret too much when cars get recalled. Usually, it's a sign that manufacturers are on top of things, rather than panicking to fix defects. More on Recalls Ignoring Over-the-Air Updates for Your Car Could Cost You Thousands. Here's Why Over 28,000 People Complained Before GM Recalled Its 6.2-Liter V-8 'HOA President About to Show Up:' Man Says There's a Recall on Kias, Hyundais Over Brakes. Then He Shows What Can Happen 'Never Fails:' Dealership Salesman Calls Out Customers with Fuel Pump Recall. They All Make the Same Mistake Get the best news, reviews, columns, and more delivered straight to your inbox, daily. back Sign up For more information, read our Privacy Policy and Terms of Use . Share this Story Facebook X LinkedIn Flipboard Reddit WhatsApp E-Mail Got a tip for us? Email: tips@ Join the conversation ( )
