Brake Recall Affects 274K Ford Expeditions and Lincoln Navigators
The full-size SUVs' front brake lines can become damaged, leak brake fluid, and then cause the front brakes to not work properly.
The recall affects 273,789 models, which Ford says will need to be inspected and possibly repaired by a dealer.
Ford is issuing another brake-related recall that once again affects the Expedition full-size SUV as well as its more luxurious counterpart, the Lincoln Navigator. Unlike last month's recall, which involved 2017–2018 models, the latest one affects newer 2022–2024 models. In total, Ford is recalling nearly 274K units, including 223,315 Expeditions and 50,474 Navigators, though only 1 percent of that population is expected to have the defect.
Marc Urbano
|
Car and Driver
The recall stems from an issue with the SUVs' front brake lines, which can contact a part of the engine air cleaner and become damaged. That can lead to leaking brake fluid and reduced brake function, which would increase the risk of a crash. That's according to a recall report that Ford filed with the National Highway Traffic Safety Administration (NHTSA) on May 9. In the previous recall, a potential brake-fluid leak was the result of a faulty master cylinder.
Ford is telling Expedition and Lincoln Navigator owners involved in the recall to take their vehicles to a dealer to be inspected. If the brake line or air-cleaner outlet pipe needs to be replaced, it will be covered free of charge. Ford says dealers are expected to be notified by today, and owners are expected to be notified by May 30.
Eric Stafford
Managing Editor, News
Eric Stafford's automobile addiction began before he could walk, and it has fueled his passion to write news, reviews, and more for Car and Driver since 2016. His aspiration growing up was to become a millionaire with a Jay Leno–like car collection. Apparently, getting rich is harder than social-media influencers make it seem, so he avoided financial success entirely to become an automotive journalist and drive new cars for a living. After earning a journalism degree at Central Michigan University and working at a daily newspaper, the years of basically burning money on failed project cars and lemon-flavored jalopies finally paid off when Car and Driver hired him. His garage currently includes a 2010 Acura RDX, a manual '97 Chevy Camaro Z/28, and a '90 Honda CRX Si. Read full bio
Hashtags
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
Car and Driver
6 minutes ago
- Car and Driver
Unfair Fight? 2002 Subaru Impreza WRX vs. Audi S4 Quattro and BMW 330xi
From the October 2001 issue of Car and Driver. The Law of Diminishing Returns: A yield rate that, after a certain point, fails to increase proportionately to additional outlays of capital or investments of time and labor.* *American Heritage Dictionary, Houghton Mifflin Company, 1992. Relax, we're not about to launch into a sleep-inducing lecture on money supply, interest rates, and the effects of Alan Greenspan's bedtime rituals on the Gross Domestic Product. The definition is for those of you who are wondering how we could even think of comparing a car costing $25,000 with two that each cost 60 percent more. The question here is: If you spend that extra 60 percent—40 thousand bucks in all—do you get a car that is 60 percent better? In the 40-grand corner we have the Audi S4 Quattro and the BMW 330xi. In the other corner—actually, down in the bargain basement—lurks our underdog, the $24,520 samurai challenger, the Subaru Impreza WRX. Unfair comparison, you say? Duuuh! But wait—check the spec sheets. All three cars have full-time four-wheel drive, four doors, manual transmissions, engines with 225 or more horsepower, and interior and exterior dimensions that come within inches of one another. View Photos JEFFREY G. RUSSELL | Car and Driver Our glowing reviews of the WRX suggest it's a worthy opponent to two of our favorite sporting sedans. The snorty little Subaru sedan has rocked the sporting establishment by producing a remarkable combination of performance and character for the price. We only decided to send it to the wolves after we looked at other similarly priced sedans and realized that matching them against the WRX wouldn't be a comparo, it'd be a slaughter. So we called in the German sharks. Both the Audi and the Bimmer have been frequent honorees on our 10Best list (10 straight years for the 3-series and three years for the S4's less-powerful sibling, the A4). Audi's S4 is a pumped-up, twin-turbocharged version of the A4 and has the added distinction of being the first and only car to outperform the previous-generation M3 in a comparison test. While the M3 has moved up in price—to $46,000—and in performance, BMW has also upped the performance of the entire 3-series line. The model representing a step down from the new M3 is the 330i, offered in both two- and four-door bodies and available with a $1750 four-wheel-drive system that changes the model designation to 330xi. Ask any one of us to pick our favorite cars, and these three would be high on our list. View Photos JEFFREY G. RUSSELL | Car and Driver If you're thinking we've put ourselves in the unenviable position of having to choose a favorite child in this test, you would be right. We put the three through our usual battery of performance tests, lapped DaimlerChrysler's 1.7-mile road course, and tore up the curvy roads of northwestern Pennsylvania—a fitting locale since the discovery and eventual refinement of oil in these hills made fortunes for many and changed the country's path nearly 150 years ago. And, of course, without oil we wouldn't be writing this. Many of us have been quick to point out that there's no need to spend more than $25,000 on a car. Do the German cars deliver the goods to justify their major-league prices? Let's find out. 3rd Place: BMW 330xi View Photos JEFFREY G. RUSSELL | Car and Driver Let this comparo remind all the whiners out there that we don't automatically place the trophy in the trunk of the car bearing the whirling propeller badge before the test. In this one, the Bimmer finished last. What gives? Clearly, this BMW wasn't loaded to compete with the two others. Its 225-hp six-cylinder engine is the least powerful of the group, and it's pushing around the second-heaviest weight. At the drag strip, it lost the sprint to 60 and through the quarter-mile. Still, we love its engine. Neither of the other cars can match the throttle response of the Bimmer's six, which doesn't bear the burden of spooling up turbos. Comments such as "power oozes out in silky-smooth pulses" and "very smooth and strong and makes the best noise" filled the BMW's logbook. HIGHS: Supple ride, slick transmission, graceful moves, silky engine. LOWS: Flat seats, few features for a $40,000 car, underwhelming grip, revs too high on the highway. VERDICT: We expect more from a BMW, especially a $40,000 one. View Photos JEFFREY G. RUSSELL | Car and Driver View Photos JEFFREY G. RUSSELL | Car and Driver We also thought the five-speed was the best-shifting box of the bunch, with low effort and Teflon-coated detents. The transmission routes power to a planetary center differential that under no-slip conditions supplies the rear axle with 62 percent of the torque. Should one wheel slip, the electronic traction control of the Bimmer's Dynamic Stability Control system routes the power to the wheels with grip. The rearward torque bias preserves the rear-drive handling we've come to appreciate in BMWs, but sadly, BMW doesn't offer on four-wheel-drivers the optional stiffer suspension and larger wheels and tires of the 3-series Sport package. The setup of the base model is softly tuned and has weak tires. "Definitely the Cadillac of the group," complained one tester. The Cadillac of the group? A BMW? It was also the quietest. We're not above appreciating a good-riding car, but unfortunately for the BMW, neither of the other cars was unduly harsh, so the BMW came across as somewhat floppy. View Photos JEFFREY G. RUSSELL | Car and Driver And then there are the tires, which squeal at even modest cornering speeds. The tires and the soft suspension conspire to hurt the BMW in every test of grip. The Bimmer finished the poorest on the skidpad and in the lane-change maneuver. On the road course, the 330xi rolled in the turns and the tires howled in protest, limiting cornering speeds and putting it 3.4 seconds behind the Audi and 1.8 seconds back of the Subaru. BMW has heard complaints that the base 3-series is too soft and in response has made the Sport suspension—but not the tires—standard on all 3-series produced after last March. That change was too late for this roundup, and any egg that appeared on the BMW's grille from its performance on the road course quickly flew off when we hit the back roads. The soft suspension displayed a fluidity we hadn't anticipated after those disappointing track laps. We still don't endorse the trend to light steering, but the brakes had the best feel of the bunch, with a firm pedal and perfect linear action. If you're still incredulous over the BMW's third-place finish, consider the features content of the Bavarian car, which at nearly 40 large as tested came with lousy, nearly flat seats that are covered in "leatherette." Sounds like a covering better suited to a $25,000 car, doesn't it? 2nd Place: Subaru WRX View Photos JEFFREY G. RUSSELL | Car and Driver We're still arguing the Subaru's second-place finish. Two of the three voters put the Subaru in first place, with the Audi second. But one—and he'll remain nameless—put the Audi first and the Subaru last, so when we averaged the scores, the Subaru missed the top spot by just one point. So what's missing in the $25,000 car? Actually, it's not what's missing, it's what's there, and in the case of the Subaru, there's a lot of extra noise. The Subaru's sound levels were the loudest during all our decibel tests. The WRX does not qualify as a loud car compared with others in its price class, but it becomes one when the competition gets very expensive. Poke around the Subie's exterior and interior panels, and you see how the noise trickles through to the inside of the car. There's only a paper-thin mat on the trunk bottom and no covering for the underside of the trunklid or hood—items both the BMW and Audi have. HIGHS: Killer value, seats, handling, and turbo 00mph. LOWS: Freeway hum. VERDICT: If you can find a better $24,520 car, buy it. View Photos JEFFREY G. RUSSELL | Car and Driver So the Subaru has less sound-deadening material. The major parts of the interior—the sharp-looking metallic-ringed gauges, the Momo steering wheel, the center console— are all impressive, but the WRX's remaining plastic trim is much flimsier than that in the pricey cars, particularly the handsome Audi. The plus side to the frugal use of sound-deadening material is the WRX's light weight. The Subaru weighs 433 pounds less than the BMW and is 560 pounds lighter than the porky Audi. That said, two of the test drivers weren't annoyed at all by the noise levels. All of us loved the wonderfully designed and supportive cloth seats, the favorite chairs of the group. We also liked the Subaru's in-dash CD changer and cassette player, a combination unique in this zooty group. The Subaru also has no power seats, no stability control, no automatic climate control, and no sunroof. That nose-dived its features rating, but to us, many of those goodies fall under the "nice to have but you don't need them" category. View Photos JEFFREY G. RUSSELL | Car and Driver The rest of the car is pure joy. There's a touch more turbo lag than in the Audi, but we could get a better launch in the Subaru, which gave it a slight edge in the low-speed-acceleration tests. The trick is to do the unthinkable in a four-wheel-drive car: Hold the revs at five grand, and drop the clutch. The WRX's full-time four-wheel-drive system uses a viscous limited-slip center differential that routes power equally to the front and rear axles. The clutch drop breaks the tires loose for only an instant, and then the WRX leaps off the line, scooting to 60 mph in 5.4 seconds and through the quarter in 14.1 seconds at 96 mph—both the best of the bunch. Turbo lag, however, rears its head in the top-gear tests where the Subaru trails from 30 to 50 mph. Keep the engine rpm north of 3000, however, and you won't notice the lag. We also found the Subaru to be the most neutral-handling of the group. Midcorner throttle lifts cause the rear end to slide just enough to tighten your line without provoking fears of a major spin. "Subaru got the big stuff right—the motor, transmission, seats, and handling," wrote one tester in the logbook. That sums up how we feel about this car. One can only marvel at what Subaru could do with another 15 grand. 1st Place: Audi S4 Quattro View Photos JEFFREY G. RUSSELL | Car and Driver So, you say there's no mystery to the Audi's win. Why wouldn't the most expensive car in the test win? Its as-tested price is $1659 above the BMW's and a universe beyond the Subaru's sticker—exactly $16,262 more. Likewise, you get a ton of stuff—power, torque, valves, features, gears, grip, and pounds in this contest. But you don't get the quickest sprinter to 60 mph. Owing to its greater girth and tires that refuse to break loose at the moment of launch despite our best efforts, the Audi trailed the Subaru to 60 mph by a smidge, 0.1 second. By 100 mph, however, the Audi had picked up enough steam to be a half-second ahead of the two other cars, and it continued to widen the gap to its governed 142-mph top speed. But the Audi is the king of every other performance contest, posting significantly better numbers on the skidpad (Audi, 0.86 g; Subaru, 0.82 g; BMW, 0.78 g), through the lane change (67.8 mph versus 66.5 for the Subaru and 63.1 for the BMW), and around the road course, where it was nearly two seconds a lap quicker than the second-place finisher, the Subaru. HIGHS: First-class cabin appointments, potent turbo mill, tenacious chassis. LOWS: Touchy brakes, rubbery shifter. VERDICT: Feels like a $40,000 car. View Photos JEFFREY G. RUSSELL | Car and Driver The Audi is the amusement ride of this group—sit down, buckle up, and hit the button. It's the easiest to drive of the trio, with benign handling and nearly telepathic steering. "The most enjoyable and secure car to drive fast. The rubber really bites in the corners, and the engine pumps power like a fire hose," said one test driver. Which brings us to the wonderful twin-turbocharged 30-valve V-6 engine. There's noticeably less turbo lag in the Audi than in the Subaru. The S4's engine enjoys a considerable displacement edge over the Subaru, so it feels more powerful off-boost. Plus, it runs less boost pressure (10.2 versus 14.2) and employs two blowers, which spool up faster than the Subie's single unit. Unfortunately, the six-speed's action is best described as rubbery. The gearbox routes power to a four-wheel-drive system that uses a Torsen limited-slip center differential to send power to the axle with the most grip, so the traction control only has to limit slip from side to side. Like all the systems here, it's transparent under normal driving conditions. View Photos JEFFREY G. RUSSELL | Car and Driver In addition to the shifter, the powerful brakes drew disparaging comments as well, despite their ability to stop the car from 70 mph in only 164 feet. "There's lots of pedal to push through before the brakes retard, and then the binders are way too touchy," mused one tester. Yet those two niggles did not alter our appreciation of this car's great versatility. Not only is it swift, it's also plush and very serene on the highway. It's easy to drive fast, yet as comfy as a La-Z-Boy. And no one can dispute the attractiveness and quality of the Audi's interior—its subdued hues and materials would fit nicely in a car costing twice as much. And as much as we liked the S4 model, it still came achingly close to being beaten by a car that is hugely less expensive. Perhaps it's not right to say that the S4 is 60 percent better than the WRX. Maybe the best way to put it is that in this test, our collective minds simply liked the S4 60 percent more. Car and Driver Specifications Specifications 2001 Audi S4 Vehicle Type: front-engine, all-wheel-drive, 5-passenger, 4-door sedan PRICE Base/As Tested: $40,782/$39,534 ENGINE twin-turbocharged and intercooled DOHC 30-valve V-6, iron block and aluminum heads, port fuel injection Displacement: 163 in3, 2671 cm3 Power: 250 hp @ 5800 rpm Torque: 258 lb-ft @ 1850 rpm TRANSMISSION 6-speed manual CHASSIS Suspension, F/R: multilink/multilimk Brakes, F/R: vented disc/vented disc Tires: Pirelli P6000 225/45YR-17 DIMENSIONS Wheelbase: 102.6 in Length: 176.7 in Width: 72.7 in Height: 54.9 in Curb Weight: 3652 lb C/D TEST RESULTS 60 mph: 5.5 sec 1/4-Mile: 14.2 sec @ 97 mph 100 mph: 15.0 sec 120 mph: 23.1 sec Rolling Start, 5–60 mph: 6.6 sec Top Gear, 30–50 mph: 8.7 sec Top Gear, 50–70 mph: 7.4 sec Top Speed (gov ltd): 142 mph Braking, 70–0 mph: 164 ft Roadholding, 300-ft Skidpad: 0.86 g C/D FUEL ECONOMY 950-Mile Trip: 21 mpg EPA FUEL ECONOMY City/Highway: 17/24 mpg -- 2001 BMW 330xi Vehicle Type: front-engine, all-wheel-drive, 5-passenger, 4-door sedan PRICE Base/As Tested: $36,385/$39,123 ENGINE DOHC 24-valve inline-6, aluminum block and head, port fuel injection Displacement: 182 in3, 2979 cm3 Power: 225 hp @ 5900 rpm Torque: 214 lb-ft @ 3500 rpm TRANSMISSION 5-speed manual CHASSIS Suspension, F/R: struts/multilink Brakes, F/R: vented disc/vented disc Tires: Continental ContiTouring Contact DIMENSIONS Wheelbase: 107.3 in Length: 176.0 in Width: 68.5 in Height: 56.5 in Curb Weight: 3525 lb C/D TEST RESULTS 60 mph: 5.7 sec 1/4-Mile: 14.4 sec @ 96 mph 100 mph: 15.5 sec 120 mph: 25.2 sec Rolling Start, 5–60 mph: 6.6 sec Top Gear, 30–50 mph: 8.3 sec Top Gear, 50–70 mph: 8.2 sec Top Speed (gov ltd): 129 mph Braking, 70–0 mph: 175 ft Roadholding, 300-ft Skidpad: 0.78 g C/D FUEL ECONOMY 950-Mile Trip: 24 mpg EPA FUEL ECONOMY City/Highway: 20/27 mpg -- 2002 Subaru Impreza WRX Vehicle Type: front-engine, all-wheel-drive, 5-passenger, 4-door sedan PRICE Base/As Tested: $24,520/$24,520 ENGINE turbocharged and intercooled flat-4, aluminum block and heads, port fuel injection Displacement: 122 in3, 1994 cm3 Power: 227 hp @ 6000 rpm Torque: 217 lb-ft @ 4000 rpm TRANSMISSION 5-speed manual CHASSIS Suspension, F/R: struts/struts Brakes, F/R: vented disc/disc Tires: Bridgestone Potenza RE92 205/55VR-16 DIMENSIONS Wheelbase: 99.4 in Length: 173.4 in Width: 68.1 in Height: 56.7 in Curb Weight: 3092 lb C/D TEST RESULTS 60 mph: 5.4 sec 1/4-Mile: 14.1 sec @ 96 mph 100 mph: 15.5 sec 120 mph: 25.2 sec Rolling Start, 5–60 mph: 6.6 sec Top Gear, 30–50 mph: 14.2 sec Top Gear, 50–70 mph: 10.0 sec Top Speed: 142 mph Braking, 70–0 mph: 181 ft Roadholding, 300-ft Skidpad: 0.82 g C/D FUEL ECONOMY 950-Mile Trip: 23 mpg EPA FUEL ECONOMY City/Highway: 20/27 mpg C/D TESTING EXPLAINED
Motor 1
36 minutes ago
- Motor 1
The Latest Mustang GTD Ditches Paint for Pure Carbon
The Ford Mustang GTD is the most radical version of the model we have ever seen, and the Blue Oval has somehow taken it even further. The automaker has unveiled the GTD Liquid Carbon that passes on a coat of paint for a completely exposed carbon-fiber body. The car is about 13 pounds lighter than the GTD Carbon Series with the Performance pack. Not only did Ford save a few pounds with the paint, it also replaced the sheet metal in the doors with bonded carbon-fiber, and in the performance world, every pound counts. One of the car's most striking features is the impeccable weave in the carbon fiber. It takes the artistry of the Carbon Series and ramps it up, featuring a cohesive pattern across the entire vehicle, matching down the midline through the hood, roof, wing, and rear duck. The Liquid Carbon comes standard with the GTD's Performance package , which includes 20-inch magnesium wheels that conceal the Black Brembo brakes with anodized GTD script. The pack also includes additional aero bits while removing some sound deadening. The Liquid Carbon features Ford's supercharged 5.2-liter V-8 engine, producing 815 horsepower and 664 pound-feet of torque, and the semi-active rear inboard pushrod suspension. 15 Source: Ford Inside, the Mustang features black leather and Dinamica microfiber suede. Hyper Lime stitching on the seats, door panels, steering wheel, and elsewhere throughout the cabin adds contrast. Ford says it will deliver the first Liquid Carbon Mustang GTD this October, joining the GTD Spirit of America as a variant. We imagine it'll cost quite a bit more than the model's $327,000 starting price . Is it worth it? More From Ford: Ford Isn't Giving Up on Regular Cars: 'You'll Be Pleasantly Surprised' Ford's $30,000 Truck Isn't a Slate Competitor. It's Something Different Stay informed with our newsletter every weekday back Sign up For more information, read our Privacy Policy and Terms of Use . Source: Ford Share this Story Facebook X LinkedIn Flipboard Reddit WhatsApp E-Mail Got a tip for us? Email: tips@ Join the conversation ( )
Yahoo
4 hours ago
- Yahoo
Rotisserie-Restored 1971 Ford Torino GT Offered With Marti Documentation
⚡️ Read the full article on Motorious Show-quality 1971 Ford Torino GT, 351C V-8, Shaker scoop and Marti documentation, offered after rotisserie restoration with period-correct details. A meticulously restored 1971 Ford Torino GT — finished in Light Pewter Metallic with period 'laser' side stripes — has been listed for sale with comprehensive provenance and a long menu of factory-style equipment, the seller said. The SportsRoof coupe is powered by Ford's 351-cubic-inch Cleveland V8 with a four-barrel carburetor and paired to a C6 Select-Shift Cruise-O-Matic automatic transmission. A 3.25:1 rear axle ratio, power steering and power front disc brakes round out a driveline calibrated for highway cruising and confident stops. The restoration presents as a full rotisserie effort, with the car returning in colors and trim that match its factory specification. According to the listing, documentation includes an Elite Marti Report, the original window sticker and an electrical traveler inspection sheet from Ford's Atlanta Assembly Plant. The car's early history cites delivery to Golden Motors Inc. in Golden, Colorado. The underside of the deck lid bears the autograph of Bill Shenk, credited as the designer of the 1970 Torino. Visually, the Torino GT wears hallmark cues from the nameplate's early-'70s peak: hidden headlamps, a Shaker hood scoop with twist locks, dual color-keyed sport mirrors (left remote), rear 'sport slats' window louvers, tinted glass and the Visibility Group lighting package. Firestone Wide Oval raised-white-letter tires are mounted on Ford Magnum 500 wheels, reinforcing the period look. The cabin presents in black vinyl with high-back bucket seats, a center console and seat belts front and rear. Amenities include a Custom Autosound radio, air conditioning and heat. The seller notes a cleanly finished dashboard and trim, with attention paid to restoring switchgear, lenses and soft materials in line with the car's overall show-quality presentation. Mechanically, the listing emphasizes a smooth-running 351C and sorted ancillary systems. While exact mileage since restoration was not disclosed, the vehicle is described as turnkey, with additional walk-around video and more than 150 photos available for review. Prospective buyers are encouraged to verify option codes against the Marti Report and inspect typical Torino corrosion points, suspension bushings and brake hydraulics as part of routine due diligence. The Torino GT was positioned by Ford as a blend of fastback style and big-car comfort, and values have strengthened as period-correct examples with documentation become scarcer. This car's combination of factory-appropriate equipment, verified build data and show-level finish — capped by a designer's signature — is likely to attract bidders seeking a blue-chip slice of Ford's muscle-era portfolio. The seller says nationwide shipping assistance is available and third-party inspections are welcome prior to purchase.
