Air India pilot's chilling question seconds before deadly crash revealed – as probe finds switch issue flagged in 2018

Scottish Sun

12-07-2025

Click to share on X/Twitter (Opens in new window)
Click to share on Facebook (Opens in new window)
ONE of the pilots operating the doomed Air India flight asked why fuel was cut off just seconds after takeoff, a preliminary report has found.
Initial investigation of the Boeing 787 Dreamliner's Black Box indicates a possibility that the pilots may have made an error while operating the flight bound for London.
Sign up for Scottish Sun
newsletter
Sign up
12
People look at the debris of an Air India plane that crashed in Ahmedabad of India's Gujarat state
Credit: Alamy
12
A view of the site where a plane crashed shortly after takeoff from Sardar Vallabhbhai Patel International Airport
Credit: Getty
12
Debris at the site of a plane crash near Sardar Vallabhbhai Patel International Airport
Credit: EPA
12
Captain Sumeet Sabharwal was the lead pilot
12
Clive Kunder was the co-pilot on the doomed flight
12
The plane seconds before disaster with its landing gear still extended
Credit: x/nchorAnandN
All but one of the 242 passengers and crew died when the flight crashed into a medical hostel just seconds after taking off - with Vishwash Ramesh, 40, the only one to survive.
Another 19 people were killed on the ground in Ahmedabad.
A 15-page preliminary report into the crash, released by the Indian authorities last night, indicates switches to the engines' fuel supplies were moved from the "RUN" position to "CUTOFF".
"The Engine N1 and N2 began to decrease from their take-off values as the fuel supply to the engines was cut off," the report said.
This could have triggered a loss of thrust, which resulted in the jet ploughing into a medical college.
Analysis of the cockpit voice recording revealed that one of the pilots asked: 'Why did you cut off?"
To which the other pilot replied: 'I didn't."
Though the report does not identify which comments were made by the flight's captain and which were made by the first officer.
Another sign that the switches were turned off was the deployment of the plane's emergency power system, a ram air turbine or RAT, which was pictured hanging down from the flight during its last moments.
Fuel switches are typically flipped to "CUTOFF" position after a flight safely touches down and reaches the airport gate.
Second-by-second breakdown of Air India jet disaster from mayday call to horror crash – all within a minute of takeoff
Or it is done in case of a certain emergency situation, such as the event of an engine fire.
But the inconclusive report, which came after 30 days of the crash, does not indicate that the flight encountered any such emergency situation.
It is almost impossible to turn the switches off accidentally - they must be pulled up and locked before flipping - a safety design feature that was introduced decades ago.
Protective guards are further installed to minimise the risks - raising further questions as to why the fuel switches in the Air India flight were turned off.
Sources say the black box analysis has so far been unable to rule out 'improper, inadvertent or intentional' action that caused them to be flipped.
Interestingly, the report points out that the US Federal Aviation Administration in 2018 issued a Special Airworthiness Information Bulletin (SAIB) - highlighting that a few Boeing 737 fuel control switches were installed with the locking feature disengaged.
But it was not deemed unsafe, and no Airworthiness Directive (AD) - a legally enforceable regulation to correct unsafe conditions in a product - was issued.
It is worth noting that the same switch design is used in Boeing 787-8 aircraft, including Air India's VT-ANB Dreamliner in question.
12
A cockpit of a Boeing 787 Dreamliner aircraft
Credit: Getty
12
Rescue officials work at the site where the Air India flight crashed
Credit: AFP
12
The plane crashed into a doctor's hostel
Credit: EPA
12
The report also found that pilots were able to restart one of the engines, but failed to stop the plane from decelerating.
No significant bird activity was observed in the vicinity of the plane's flight path, the report added.
The initial investigation was led by a panel including the Indian authorities and experts from Boeing US and the UK.
Pilot Sumeet Sabharwal and co-pilot Clive Kunder had more than 14,000 hours of flying experience between them - including some 9,000 hours on the 787.
The Boeing 787 Dreamliner with 242 passengers on board - including 53 Brits - smashed into a doctors' hostel in Ahmedabad in the west of India.
The plane was headed to London Gatwick with 232 passengers and 10 crew on board when it crashed just seconds after take-off.
The Dreamliner lost contact just seconds after take-off, according to flight tracking website Flightradar.
A final alert was last logged less than a minute after it started the journey from Sardar Vallabhbhai Patel International Airport.
Seconds before the crash, the Boeing was filmed flying low over the Meghani Nagar residential area with the pilots appearing to be in a desperate bid to keep the plane in the air.
Moments later, it was seen disappearing behind buildings before a huge blast was seen in the distance.
Brit passenger Vishwash Kumar Ramesh, 40, was the sole survivor of the fatal crash.
He cheated death after being flung from seat 11A on the flaming Air India jet - escaping with minor injuries and filmed walking away after the wreck.
Incredible footage showed him walking away from the wreckage almost unscathed.
Flanked by the locals, he can be seen making his way towards an ambulance with blood caking his face.
Speaking in Hindi, he says: "I just got out of the plane, it exploded."
12
Indian Prime Minister Narendra Modi visiting the only survivor in an Air India plane crash at a hospital in Ahmedabad
Credit: Alamy
12
Vishwash Ramesh, the sole survivor of the Air India crash, poses for the first time since the disaster
Credit: Dan Charity