logo
Substation fire that shut down Heathrow was caused by moisture flagged as a problem SEVEN YEARS earlier but left unrepaired

Substation fire that shut down Heathrow was caused by moisture flagged as a problem SEVEN YEARS earlier but left unrepaired

Daily Mail​13 hours ago
The substation fire that shut down Heathrow Airport for a whole day was caused by moisture which was first flagged as a problem seven years ago but left unrepaired.
Energy watchdog Ofgem has launched an investigation after a new report found the fire, which broke out on March 20 in Hayes, west London, was due to a preventable technical fault.
More than 270,000 air passenger journeys were disrupted by the fire, which forced the UK's busiest airport to close for almost an entire day.
The subsequent electricity outage led to 71,655 domestic and commercial customers losing power and the 'complete loss of supplies' to part of Heathrow Airport's internal electrical distribution network, a new report has said.
The report by the National Energy System Operator (Neso) said an 'elevated moisture reading' had been found in oil samples at the North Hyde substation in west London in July 2018, but action was not taken to replace electrical insulators known as bushings.
In 2022, a decision was made to 'defer basic maintenance' at the substation, meaning the issue went 'unaddressed', the final report said, meaning that electrical insulators known as bushings were not replaced.
On Wednesday, Ofgem said it had opened an official enforcement investigation into National Grid Electricity Transmission (NGET) based on the Neso review's findings.
The fire was caused by a 'catastrophic failure' in one of the transformers, 'most likely caused by moisture entering the bushing causing a short circuit', which ignited the oil, the Neso report said.
A review by the National Grid in 2022 found the fire suppression system at the North Hyde site was 'inoperable', while another assessment in July 2024 indicated the system was still 'out of service', the report said.
No flights operated at the west London airport until about 6pm on March 21 because of the blaze which started late the previous night.
Akshay Kaul, director general for infrastructure at Ofgem, said: 'The North Hyde substation fire resulted in global disruption, impacted thousands of local customers, and highlighted the importance of investment in our energy infrastructure.
'As a result of the report's findings, we have opened an investigation into National Grid Electricity Transmission.
'We have also commissioned an independent audit of their most critical assets.
'Ofgem will also further examine the incident and its causes and take further action as appropriate.
'We expect energy companies to properly maintain their equipment and networks to prevent events like this happening.
'Where there is evidence that they have not, we will take action and hold companies fully to account.
'Britain has one of most reliable energy systems in the world and thankfully incidents like this are rare. We must continue to invest in the system to maintain that resilience.'
Outcomes from Ofgem's investigation could include a finding of no breach, or compliance action to bring companies into compliance, along with potential contributions to the voluntary redress fund, penalties and licence revocation.
The Neso report, which was published on Wednesday and commissioned by Energy Secretary Ed Miliband, read: 'An elevated moisture reading in one of SGT3's (the transformer's) bushings had been detected in oil samples taken in July 2018.
'According to National Grid Electricity Transmission's relevant guidance, such readings indicate 'an imminent fault and that the bushing should be replaced.
'While the reading was recorded in National Grid Electricity Transmission's online system, the mitigations appropriate to its severity were not actioned.
'The controls in place were not effective and failed to identify subsequently that action had not been taken in relation to the elevated moisture reading.
'This includes an opportunity in 2022 when a decision was taken to defer basic maintenance on SGT3. The issue therefore went unaddressed.'
The report continued: 'The July 2024 fire risk assessment stated that if a fire started on any of the three supergrid transformers, 'it would not be suitably suppressed'.
'As a result, a high priority action was created on the pump of the water mist system to be appropriately serviced and maintained.
'That action remained outstanding at the time of the incident, in March 2025.
'National Grid Electricity Transmission stated that it was planning a combination of replacements and refurbishments of the fire suppression system by October 2025.'
The Neso review also found that the design and configuration of Heathrow's internal power network meant the loss of just one of its three supply points would 'result in the loss of power to operationally critical systems, leading to a suspension of operations for a significant period'.
Plans were in place to respond to such an event, including the reconfiguration of the network which would take approximately 10 to 12 hours, but the loss of a supply point was 'not assessed to be a likely scenario by Heathrow Airport Limited, due to its expectation of the resilience of the wider network', the report said.
'This meant that its internal electrical distribution network was not designed or configured to take advantage of having multiple supply points to provide quick recovery following such a loss and relied on manual switching.'
Mr Miliband said: 'The report is deeply concerning because known risks were not addressed by the National Grid Electricity Transmission, and Ofgem has now opened an official enforcement investigation to consider any possible licence breaches relating to the development and maintenance of its electricity system at North Hyde.
'There are wider lessons to be learned from this incident. My department, working across Government, will urgently consider the findings and recommendations set out by Neso and publish a response to the report in due course.'
A Heathrow spokesperson said: 'Heathrow welcomes this report, which sheds further light on the external power supply failure that forced the airport's closure on 21 March.
'A combination of outdated regulation, inadequate safety mechanisms and National Grid's failure to maintain its infrastructure led to this catastrophic power outage.
'We expect National Grid to be carefully considering what steps they can take to ensure this isn't repeated.
'Our own review, led by former cabinet minister Ruth Kelly, identified key areas for improvement and work is already under way to implement all 28 recommendations.'
Heathrow is Europe's largest airport with more than 83.9 million passengers travelling through its terminals in 2024.
A National Grid spokesperson said: 'As Neso's report sets out, in Great Britain we have one of the most reliable networks in the world, and events of this nature are rare.
'National Grid has a comprehensive asset inspection and maintenance programme in place, and we have taken further action since the fire. This includes an end-to-end review of our oil-sampling process and results, further enhancement of fire risk assessments at all operational sites, and retesting the resilience of substations that serve strategic infrastructure.
'We fully support the recommendations in the report and are committed to working with Neso and others to implement them. We will also co-operate closely with Ofgem's investigation.
'There are important lessons to be learnt about cross-sector resilience and the need for increased co-ordination, and we look forward to working with government, regulators and industry partners to take these recommendations forward.'
A spokesperson for Heathrow said the National Grid's 'failure to maintain its infrastructure' led to the power outage.
The spokesperson said: 'Heathrow welcomes this report, which sheds further light on the external power supply failure that forced the airport's closure on March 21.
'A combination of outdated regulation, inadequate safety mechanisms, and National Grid's failure to maintain its infrastructure led to this catastrophic power outage.
'We expect National Grid to be carefully considering what steps they can take to ensure this isn't repeated.
Orange background

Try Our AI Features

Explore what Daily8 AI can do for you:

Comments

No comments yet...

Related Articles

EXCLUSIVE McVities forces British biscuit museum to axe Jaffa Cakes exhibit for 'misclassifying' sweet treat as a biscuit
EXCLUSIVE McVities forces British biscuit museum to axe Jaffa Cakes exhibit for 'misclassifying' sweet treat as a biscuit

Daily Mail​

time18 minutes ago

  • Daily Mail​

EXCLUSIVE McVities forces British biscuit museum to axe Jaffa Cakes exhibit for 'misclassifying' sweet treat as a biscuit

McVities has encouraged a UK biscuit museum to scrap a Jaffa Cakes exhibit because they ' misclassified' the sweet treat as a biscuit, MailOnline can exclusively reveal. Most Britons will agree that Jaffa Cakes are a classic British sweet treat, but when it comes to categorising them as a cake or a biscuit, there's much less consensus. That's why Peak Freans Biscuit Museum in Bermondsey, London, found itself in a sticky situation on Monday after dedicating an exhibit to the chocolate-covered treat, first introduced by McVities in 1927. The exhibit caused a stir at McVities because, as indicated by the treat's name, the snack food brand believes Jaffa Cakes are a cake, not a biscuit, meaning they don't belong at a biscuit museum. And to set the record straight, the brand sent the museum an entertaining cease-and-desist-esque letter requesting the removal of the exhibit earlier this week. 'Dear Sirs, Madams, and Biscuit Enthusiasts,' the letter from McVities began, continuing, 'It has come to our attention, with no small degree of dismay, that the Biscuit Museum has included the humble Jaffa Cake within its exhibition of biscuitry. 'We write to you today, not with crumbs of animosity, but with a full slice of firm objection. Allow us to be clear: Jaffa Cakes are, in fact, cakes. 'Not biscuits. Not hybrid snacks. Just cakes. Some would say the clue is in the name on the box.' McVitie's and the biscuit museum are yet to agree on the debate. In response to the exhibition launch, a spokesperson for McVitie's said, 'Look, we love a good biscuit as much as the next snack enthusiast, but we've got to draw the line somewhere, and that line is sponge-based. 'We respect the Biscuit Museum's enthusiasm, but a cake's a cake, even when it's small, round, and lives suspiciously close to Hobnobs. It's nothing personal, it's just the way the cake crumbles.' Staff at the museum voiced surprise at McVitie's response. The Biscuit Museum's curator, Gary Magold, said, 'It's a shame - we've had to remove the exhibition for the moment. But, as a nation of Jaffa Cakes lovers, we're hoping we can reach an agreement.' It comes after people voiced surprise after learning what makes the delicious filling inside a Jammie Dodger. The popular British biscuit is made of two round shortbreads sandwiched together by a rich jammy red filling and famously stamped with a small red heart. Jammie Dodgers - which often retail for as little as £1 or less at supermarkets like Asda and Tesco - come in a variety of flavours including raspberry and strawberry. But fans have been left shocked to discover that the beloved sweet snacks contain neither fruit, but rather a totally different one altogether. According to a Facebook post, the popular treat achieve their wondrous filling using apple jam. The biscuits also feature a raspberry filling, which gives it the famous taste fans have come to love. Meanwhile the strawberry variation - which comes in a pink packet - also uses apple jam in its ingredients - and likewise contains strawberry flavouring. The specific ingredients of a standard 140g pack of Jammie Dodgers are listed as including 'flour', 'raspberry flavour apple jam', 'apples', 'flavourings' and 'sugar' amongst other things. Responding to the post, one person said the revelations made them 'question' everything they knew. 'Something like this makes one question everything they know and makes their world crash around them' they wrote. 'Actually, a bit like when I painstakingly reassembled my iMac earlier today, and then later found a T10 screw on the kitchen floor. I might treat myself to some Jammie Dodgers later'. It also appears the post left one person emotional, as they wrote: 'This is a HORRIBLE HORRIBLE thread.' 'Well I am flabbergasted. I always thought it was strawberry jam... good Lord' wrote another. Meanwhile, one woman explained: 'This is definitely nothing new. Many a pot of "jam" of the cheaper varieties used to be made in the same way, apple pulp because it is cheap and easy to gel, and some "flavouring" added. 'I don't know what they are like now because I make my own jam these days (and grow or forage my own fruit for them) and have done for some 30 years'. Jammie Dodgers is a popular British biscuit typically enjoyed by being dipped in tea, or as a standalone snack. After briefly adding dairy to their recipe, Jammie Dodgers reverted back to a vegan-friendly recipe in 2020, sparking joy among plant-based diet followers across the globe. Meanwhile, over the years, the biscuit has seen a variety of limited edition flavours, including toffee, lemon, and even berry blast. In 2009, they were even reportedly sent to the International Space Station as part of a care package for British astronaut Tim Peake. However, despite being one of the only British biscuit to make it to space, the debate is still strong on what is the correct way to devour the delicious snack. Taking to Instagram threads Danny, from Leeds, asked his followers the pressing question. He wrote: 'How do you eat your Jammie Dodgers? I think I eat mine the weirdest way. Eat the top edge, eat the bottom edge and then boom centre goes in one.' Many rushed to the comments with their own way to eat the biscuit. One person wrote: 'Nibble all the outside and the biscuit leaving the jam then eat that…yes I'm weird.' Another said: 'I'm the same. Save the best till last.' While someone else agreed adding: 'Leaving the jam bit until last.'

Lottery results and numbers: Lotto and Thunderball draw tonight, July 2, 2025
Lottery results and numbers: Lotto and Thunderball draw tonight, July 2, 2025

The Sun

time2 hours ago

  • The Sun

Lottery results and numbers: Lotto and Thunderball draw tonight, July 2, 2025

THE NATIONAL Lottery results are in and it's time to find out who has won a life-changing amount of money tonight (July 2, 2025). Could tonight's £8.4 million jackpot see you handing in your notice, jetting off to the Bahamas or driving a new Porsche off a garage forecourt? 3 3 You can find out by checking your ticket against tonight's numbers below. Good luck! Tonight's National Lottery Lotto winning numbers are: 04, 11, 34, 51, 54, 55 and the bonus number is 57. Tonight's National Lottery Thunderball winning numbers are: 06, 09, 12, 20, 35 and the Thunderball number is 14. The first National Lottery draw was held on November 19 1994 when seven winners shared a jackpot of £5,874,778. The largest amount ever to be won by a single ticket holder was £42million, won in 1996. Gareth Bull, a 49-year-old builder, won £41million in November, 2020 and ended up knocking down his bungalow to make way for a luxury manor house with a pool. TOP 5 BIGGEST LOTTERY WINS ACROSS THE WORLD £1.308 billion (Powerball) on January 13 2016 in the US, for which three winning tickets were sold, remains history's biggest lottery prize £1.267 billion (Mega Million) a winner from South Carolina took their time to come forward to claim their prize in March 2019 not long before the April deadline £633.76 million (Powerball draw) from a winner from Wisconsin £625.76 million (Powerball) Mavis L. Wanczyk of Chicopee, Massachusetts claimed the jackpot in August 2017 £575.53 million (Powerball) A lucky pair of winners scooped the jackpot in Iowa and New York in October 2018 Sue Davies, 64, bought a lottery ticket to celebrate ending five months of shielding during the pandemic — and won £500,000. Sandra Devine, 36, accidentally won £300k - she intended to buy her usual £100 National Lottery Scratchcard, but came home with a much bigger prize. The biggest jackpot ever to be up for grabs was £66million in January last year, which was won by two lucky ticket holders. Another winner, Karl managed to bag £11million aged just 23 in 1996. The odds of winning the lottery are estimated to be about one in 14million - BUT you've got to be in it to win it. 3

DOWNLOAD THE APP

Get Started Now: Download the App

Ready to dive into a world of global content with local flavor? Download Daily8 app today from your preferred app store and start exploring.
app-storeplay-store