NTSB set to meet on door plug investigation of terrifying Alaska Airlines flight
The board will discuss what NTSB investigators have uncovered over the past 17 months, including their revelation that bolts securing what is known as the door plug panel were removed and never replaced during a repair. Board members were also expected to approve recommendations to keep something similar from ever happening again.
The blow out aboard Alaska Airlines flight 1282 occurred minutes after it took off from Portland, Oregon, and created a roaring air vacuum that sucked objects out of the cabin and scattered them on the ground below along with debris from the fuselage. Seven passengers and one flight attended received minor injuries, but no one was killed. Pilots were able to land the plane safely back at the airport.
The accident occurred as the plane flew at 16,000 feet (4,800 meters). Oxygen masks dropped during the rapid decompression and a few cellphones and other objects were swept through the hole in the plane as 171 passengers contended with wind and roaring noise.
The first six minutes of the flight to Southern California's Ontario International Airport were routine. The Boeing 737 Max 9 was about halfway to its cruising altitude and traveling at more than 400 mph (640 kph) when passengers described a loud 'boom' and wind so strong it ripped the shirt off someone's back.
'We knew something was wrong,' Kelly Bartlett told The Associated Press in the days following the flight. 'We didn't know what. We didn't know how serious. We didn't know if it meant we were going to crash.'
The 2-foot-by-4-foot (61-centimeter-by-122-centimeter) piece of fuselage covering an unoperational emergency exit behind the left wing had blown out. Only seven seats on the flight were unoccupied, including the two seats closest to the opening.
The panel that blew off was made and installed by a supplier, Spirit AeroSystems. It was removed at a Boeing factory so workers could repair damaged rivets, but bolts that help secure the door plug weren't replaced. It's not clear who removed the panel.
The NTSB said in a preliminary report that four bolts were not replaced after a repair job in a Boeing factory, but the company has said the work was not documented.
Boeing factory workers told NTSB investigators that they felt pressured to work too fast and were asked to perform jobs that they weren't qualified for, including opening and closing the door plug on the particular plane involved.
A Boeing door installer said he was never told to take any shortcuts, but everyone faced pressure to keep the assembly line moving.
'That's how mistakes are made. People try to work too fast,' he told investigators. The installer and other workers were not named in documents about the probe.
The Max version of Boeing's bestselling 737 airplane has been the source of persistent troubles for the company since two of the jets crashed, one in Indonesia in 2018 and another in Ethiopia in 2019, killing a combined 346 people.
Investigators determined those crashes were caused by a system that relied on a sensor providing faulty readings to push the nose down, leaving pilots unable to regain control. After the second crash, Max jets were grounded worldwide until the company redesigned the system.
Last month, the Justice Department reached a deal allowing Boeing to avoid criminal prosecution for allegedly misleading U.S. regulators about the Max before the two crashes.
But regulators at the Federal Aviation Administration have capped Boeing's 737 Max production at 38 jets per month while investigators ensure the company has strengthened its safety practices.
Boeing hired a new CEO, Kelly Ortberg, last year and created a new position for a senior vice president of quality to help improve its manufacturing.
The company was back in the news earlier this month when a 787 flown by Air India crashed shortly after takeoff and killed at least 270 people. Investigators have not determined what caused that crash, but so far they have not found any flaws with the model, which has a strong safety record.
Hashtags
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
Daily Record
12 hours ago
- Daily Record
South Lanarkshire is flying the flag for autism awareness
Autistic Pride Day was held this year on June 18. Two Hamilton pupils marked Autistic Pride Day by raising an awareness flag outside of South Lanarkshire Council's HQ. Five-year old Max and 12-year-old Caleb from St John's Primary School helped officials to raise the flag on Autistic Pride Day, which was held this year on June 18. Recognised annually, the day celebrates the importance and value of autistic people within society. And 2025 marks the seventh year that South Lanarkshire Council has flown the flag to honour Autistic Pride Day. Chair of the council's Social Work Resources Committee, Councillor Margaret Walker, said: 'The flag lets our entire autism and wider neurodivergent community know that South Lanarkshire Council is committed to raising awareness and understanding. 'It's important that people are treated with dignity, respect and listened to – and the work of the Autism Resources Co-ordination Hub (ARCH), is a great example of that.' Professor Soumen Sengupta, chief officer for health and social care, said: 'Autism Pride Day provides an important public opportunity for us to recognise the contributions of autistic members of our communities and celebrate the strength that comes from valuing diversity. 'My thanks to Max and Caleb for leading the way at the flag raising.' *Don't miss the latest headlines from around Lanarkshire. Sign up to our newsletters here. And did you know Lanarkshire Live is on Facebook?
The Herald Scotland
3 days ago
- The Herald Scotland
New details revealed about deadly ship, Brooklyn Bridge collision
The Cuauhtemoc, a 197-foot-long ship named after the last Aztec emperor, was on a monthslong training cruise that was scheduled to stop in at least 15 countries when it smashed into the iconic bridge. The crash occurred as the ship was heading to an anchorage to refuel before departing for Iceland. Videos captured the ensuing chaos as people on the shoreline and bridge span ran in terror, and Navy cadets dangled from the ship's crossbeams and sailcloth. It remains unclear why the ship was moving backward at nearly 7 mph at the time of the crash. The preliminary report did not say whether there was in issue with the ship's engines or if the vessel had lost power, as officials have previously stated. Federal investigators' full report, which will detail the likeliest cause of the crash, is ongoing and could take more than a year to complete. Timeline: How a Mexican Navy ship crashed into the Brooklyn Bridge Before 8 p.m. on May 17, a sea pilot and a local docking pilot spoke with the ship's captain, who told them "the propulsion and steering systems were in good order, and there were no deficiencies," according to the report. After assessing the visibility and weather conditions on the East River, the ship pulled away from Pier 17 in lower Manhattan around 8:19 p.m. with the help of a tugboat, the Charles D. McAllister. The docking pilot directed the ship to move backward - instructions that were acknowledged by the captain, translated into Spanish and relayed to crewmembers, the report said. Once clear of the slip, the docking pilot gave a stop command and then a dead-slow-ahead order - directing the ship to move forward at the slowest speed possible. The pilot then directed the tugboat to reposition itself on the front right side of the ship. After the tugboat detached from the vessel, the pilot "ordered additional commands in the ahead direction." As the tugboat pushed on the vessel's front right side, the ship began to swing toward the Brooklyn Bridge, according to the preliminary report. At that point, the docking pilot ordered the tugboat to back away and maneuver toward the right rear side of the ship. Around 8:24 p.m., the ship's backward speed increased from 3.7 mph to 5.8 mph and the harbor pilot called for nearby tugboat assistance. Moments later, the upper section of all three of the ship's masts collided with the span of the Brooklyn Bridge. At the time of impact, the ship was moving backward at 6.7 mph, according to the NTSB. Where are investigators in their probe? After the crash, the Cuauhtemoc was towed to a local shipyard for repairs and analysis. Investigators have boarded the ship for a preliminary examination and found scraped paint on the rear left side of the ship and a deformed rudder post. The New York City Department of Transportation inspected the Brooklyn Bridge and determined there was no significant structural damage. It was reopened soon after the crash. Federal investigators, meanwhile, have interviewed crewmembers on the ship as well as the two pilots and the tugboat crew. The preliminary report said the pilots and tugboat captain all passed drug and alcohol tests. "The NTSB investigation of all aspects of the accident is ongoing; we are examining the propulsion system, operating control system, relevant crew experience and training, and operating policies and procedures," the agency said in a statement. The estimated damage from the crash is expected to exceed $500,000, according to the report.
Daily Mirror
3 days ago
- Daily Mirror
Passengers write goodbye notes as oxygen masks deployed during plane's drop
A Japan Airlines flight suddenly dropped from 36,000 feet to 10,500 feet in 10 minutes on Monday, and passengers said they feared they might die during the terrifying ordeal Passengers on a Japan Airlines flight to Tokyo were gripped by fear on Monday when a mechanical fault in the Boeing 737 aircraft caused it to plummet nearly 26,000 feet. The plane, carrying 191 passengers and crew, dropped from roughly 36,000 feet to just below 10,500 feet within 10 minutes. Oxygen masks were released inside the cabin, sparking fears of a potential crash among those onboard. One individual was reportedly "on the verge of tears" as they hastily penned their will and financial details during the rapid descent. This frightening incident comes in the wake of a string of Boeing-related problems, including the widely reported Boeing 787 Dreamliner crash in Ahmedabad earlier in June. Japan Airlines flight JL8696 took off from Shanghai Pudong Airport in China, bound for Tokyo's Narita Airport, on Monday. At around 6:53 p, reports the Mirror US. m. local time, the aircraft began to descend at a distressing rate. An alert activated during the fall pointed to an issue with the plane's pressurisation system, according to Japan's Ministry of Land, Infrastructure, Transport and Tourism. "I heard a muffled boom, and the oxygen mask fell off in a few seconds. The stewardess cried and shouted to put on the oxygen mask, saying the plane had a malfunction," one passenger recounted, as per People. "Suddenly, all the oxygen masks popped open while I was sleeping," another passenger recounted. Fears of losing consciousness gripped some travellers as cabin pressure plummeted. The captain swiftly alerted air traffic control, issuing an emergency call, before rerouting the aircraft to Kansai International Airport in Osaka, touching down safely at 8:50 p. m. with all on board unscathed. In light of the scare, passengers were offered 15,000 yen ($93) for their troubles and a complimentary overnight stay. Authorities are currently dissecting the details of what went wrong. Another recent incident saw a Boeing 737 Dreamliner clip a parked aeroplane at Vietnam's Noi Bai International Airport, resulting in considerable damage. Boeing finds itself under scrutiny after a side exit door was dramatically lost from an Alaska Airlines plane mid-flight last year.
