Mechanical, electrical issues could also have led to change in fuel switch positions in ill-fated AI plane: Experts
They also opined that the reasons for the change in fuel switch position will be known during further investigations.
The Aircraft Accident Investigation Bureau's (AAIB) preliminary report has mentioned that fuel switches of engine 1 and 2 of the Boeing 787-8 aircraft were cut off within a gap of one second and later turned on before the crash on June 12.
Federation of Indian Pilots (FPI) President and former Air India pilot Captain C S Randhawa said the position of the fuel switches can be changed only with a human interface.
These switches are spring-loaded and have a lock. If they have to be put into RUN position, then first, it has to be pulled out and move into the position, he said.
According to him, the switches are generally used in case there has been a flameout of both engines or the pilots have recycled the switches. "It is not clear from the preliminary report as to why the position of the switches was changed", he said and added that there could also have been an interruption in the power supply.
"When the fuel control switch has to be cut off, the pilot flying will say, fuel control switch left, confirm. So, after the confirmation is made by the second pilot, the pilot monitoring will cut off (the switch).
"In this case, the first officer was taking off the aircraft and the captain was pilot monitoring. Now, did this transfer of controls take place between the captain and the first officer? It is not clear from the report at all," he noted.
The fuel switches are below the throttles.
"Now, in case of a dual engine flameout, the auto-throttle switches are put off and fuel control switches are made to cut off and run. Basically, they reactivate," he said.
A former Directorate General of Civil Aviation (DGCA) official said there was a change in the position of the fuel switches and the question is why it happened.
"Now, the investigation will lead in this direction to why this switch position changed, whether it was a mechanical failure, whether it was intentional or unintentional or anything else or if there was a problem... The question is also whether there was a software glitch and or not," he said.
In the report, there is no mention on whether there was any malfunctioning of the fuel switches earlier.
A senior Boeing commander said it is not exactly clear from the preliminary report why the fuel switch was turned to CUTOFF from RUN position. The change might have happened inadvertently, he added.
According to a senior official, who has been part of various aircraft accident investigations, investigations in the coming months will help in ascertaining the reasons, including whether there were any mechanical issues, for the change in position of the fuel switches.
"The aircraft achieved the maximum recorded airspeed of 180 Knots IAS at about 08:08:42 UTC and immediately thereafter, the Engine 1 and Engine 2 fuel cutoff switches transitioned from RUN to CUTOFF position one after another with a time gap of 01 sec.
"The Engine N1 and N2 began to decrease from their take-off values as the fuel supply to the engines was cut off.
"In the cockpit voice recording, one of the pilots is heard asking the other why did he cut off. The other pilot responded that he did not do so," the report said.
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
The Print
an hour ago
- The Print
‘No mechanical, maintenance issues with aircraft'—Air India CEO tells employees post prelim crash probe
'The Preliminary Report identified no cause nor made any recommendations, so I urge everyone to avoid drawing premature conclusions as the investigation is far from over. We will continue to co-operate with the investigators to ensure they have everything they need to conduct a thorough and comprehensive enquiry,' he said, warning that there would be sensationalism till the final report is out. 'Instead of focusing on interpretations, I suggest we note that the Preliminary Report found no mechanical or maintenance issues with the aircraft or engines, and that all mandatory maintenance tasks had been completed. There was no issue with the quality of fuel and no abnormality with the take-off roll. The pilots had passed their mandatory pre-flight breathalyser and there were no observations pertaining to their medical status,' the letter said. New Delhi: No 'mechanical or maintenance issues with the aircraft or engines', is what Air India CEO Campbell Wilson Monday told AI employees in an internal letter on the initial investigation into the 12 June crash. The Air India-171 flight, a Boeing 787-8 Dreamliner was set to fly from Ahmedabad to London's Gatwick, but crashed within a minute of the scheduled take off time. The deadly crash left at least 275 people dead, including 241 out of the 242 on the plane, and others on the ground. The aircraft crashed into the BJ Medical College hostel mess building. On the intervening night of Friday and Saturday, the AAIB released its preliminary report on the crash noting that the fuel switches transitioned to 'cut-off' 1 second apart for both engines. The report notes that the fuel switches were also then moved to 'run'; while one engine ignited, the other failed. The report has ignited massive criticism from aviation experts, with many saying the pilots were being made scapegoats. Meanwhile, Campbell Monday also said, 'The release of the Preliminary Report marked the point at which we, along with the world, began receiving additional details about what took place. Unsurprisingly, it provided both greater clarity and opened additional questions. It also triggered a new round of speculation in the media. Indeed, over the past 30 days, we've seen an ongoing cycle of theories, allegations, rumours and sensational headlines, many of which have later been disproven.' 'I would also remind that, out of an abundance of caution and under the oversight of the DGCA, every Boeing 787 aircraft operating in our fleet was checked within days of the accident and all were found fit for service. We continue to perform all necessary checks, as we will any new ones that authorities may suggest,' the letter added. (Edited by Viny Mishra) Also read: Air India crash should push India to create independent board for transport safety oversight
Mint
2 hours ago
- Mint
Air India crash investigation ‘far from over', says CEO Campbell Wilson on AAIB report: ‘No issue with fuel quality…'
Air India CEO and MD Campbell Wilson on Monday stated that the Aircraft Accident Investigation Bureau's (AAIB) preliminary report on last month's fatal crash in Ahmedabad found no mechanical or maintenance faults with the aircraft or its engines. Amid speculations in various quarters about the reasons for the fatal crash that killed 260 people on June 12, the Air India chief said the preliminary report identified no cause nor made any recommendations and urged everyone to avoid drawing premature conclusions as the investigation is 'far from over'. In a message to Air India staff, Wilson on Monday said the preliminary report found no mechanical or maintenance issues with the aircraft or engines, and that all mandatory maintenance tasks had been completed, PTI reported. "There was no issue with the quality of fuel and no abnormality with the takeoff roll. The pilots had passed their mandatory pre-flight breathalyser and there were no observations pertaining to their medical status," he said. Further, Wilson said out of an abundance of caution and under the oversight of regulator DGCA, every Boeing 787 aircraft operating in our fleet was checked within days of the accident and all were found fit for service. 'We continue to perform all necessary checks, as we will any new ones that authorities may suggest,' he added. The airline, he said, will continue to co-operate with the investigators to ensure they have everything they need to conduct a thorough and comprehensive enquiry. 'The release of the preliminary report marked the point at which we, along with the world, began receiving additional details about what took place. Unsurprisingly, it provided both greater clarity and opened additional questions,' Wilson said. Over the past 30 days, he said there has been an ongoing cycle of theories, allegations, rumours and sensational headlines, many of which have later been disproven. 'Until a final report or cause is tabled, there will no doubt be new rounds of speculation and more sensational headlines... Let us not be diverted from what are our top priorities: standing by the bereaved and those injured, working together as a team, and delivering a safe and reliable air travel experience to our customers around the world,' Wilson said. He also stressed that the airline must remain focused on its task and be true to the values of integrity, excellence, customer focus, innovation, and teamwork. The Aircraft Accident Investigation Bureau (AAIB) on Saturday released its preliminary report on the crash of Air India's Boeing 787-8 plane that killed 260 people, including 241 people onboard. The aircraft, which was operating the flight AI171 from Ahmedabad to London Gatwick, crashed into a building soon after takeoff. The AAIB report said the fuel supply to both engines of flight AI171 was cut off within a second of each other, causing confusion in the cockpit and the airplane plummeting back to the ground almost immediately after taking off. The 15-page report also said that in the cockpit voice recording, one unidentified pilot asked the other why he had cut off the fuel, which the other denied.
Hindustan Times
2 hours ago
- Hindustan Times
'No mechanical, maintenance issues': Air India CEO Campbell Wilson reacts to AAIB preliminary report on crash
Air India chief executive officer (CEO) Campbell Wison on Monday said that the Aircraft Accident Investigation Bureau's (AAIB) initial report identified no cause nor made any recommendations and urged everyone to avoid drawing premature conclusions. Campbell Wilson, chief executive officer of Air India said that the AAIB's Preliminary Report found no mechanical or maintenance issues with the aircraft or engines.(Bloomberg) In a letter addressed to its employees, he defined the crash as 'a period in which not a moment has gone by without thinking of the passengers, friends, colleagues and wider community who were lost or injured.' 'The release of the Preliminary Report marked the point at which we, along with the world, began receiving additional details about what took place. Unsurprisingly, it provided both greater clarity and opened additional questions,' Wilson's mail, seen by HT, read. The CEO said that the report 'also triggered a new round of speculation in the media.' 'Instead of focusing on such interpretations, I suggest we note that the Preliminary Report found no mechanical or maintenance issues with the aircraft or engines, and that all mandatory maintenance tasks had been completed. There was no issue with the quality of fuel and no abnormality with the take-off roll. The pilots had passed their mandatory pre-flight breathalyser and there were no observations pertaining to their medical status,' Wilson stated. He said that 'out of abundance caution' every Boeing 787 aircraft operating in Air India's fleet was checked within days of the accident and all were found fit for service. 'We continue to perform all necessary checks, as we will any new ones that authorities may suggest,' the airline chief stated. Noting that the preliminary report identified no cause nor made any recommendations, Wilson said, 'I urge everyone to avoid drawing premature conclusions as the investigation is far from over. We will continue to cooperate with the investigators to ensure they have everything they need to conduct a thorough and comprehensive enquiry.' 'Until a final report or cause is tabled there will no doubt be new rounds of speculation and more sensational headlines. We must nevertheless remain focused on our task and be true to the values that have powered Air India's transformation journey over the past three years – integrity, excellence, customer focus, innovation and teamwork. Let us not be diverted from what are our top priorities: standing by the bereaved and those injured, working together as a team, and delivering a safe and reliable air travel experience to our customers around the world,' his email concluded.
