Air India replaced module in cockpit in crashed Dreamliner following Boeing directive
replaced the Throttle Control Module (TCM) of the crashed Boeing 787-8 plane twice in the last six years following a directive from Boeing in 2019, sources said on Sunday.
TCM includes fuel control switches, which have come to focus in the ongoing probe into the fatal crash as these switches were cut off immediately after takeoff of the ill-fated London-bound Dreamliner VT-ANB that crashed in Ahmedabad on June 12.
The replacement of the TCM twice -- in 2019 and 2023 -- was mentioned in the Aircraft Accident Investigation Bureau's (AAIB) preliminary probe report into the crash that was released on Saturday. It also said the TCM replacement was not linked to the fuel control switches.
by Taboola
by Taboola
Sponsored Links
Sponsored Links
Promoted Links
Promoted Links
You May Like
When Knee Pain Hits, Start Eating These Foods, and Feel Your Pain Go Away (It's Genius)
12facts.com
Read More
Undo
The source told PTI that a revised Maintenance Planning Document (MPD) was issued by Boeing for all the operators of the Dreamliners in 2019.
As per the MPD, the operators have to change the TCM, which includes the fuel control switches, every 24,000 flight hours, the sources said.
Live Events
Since 2019, when the MPD was issued, the source said Air India changed the TCM in the ill-fated aircraft twice -- in 2019 and 2023.
Queries sent to Air India remained unanswered.
Specific details about the MPD could not be immediately ascertained.
In response to questions sent to Boeing, a company spokesperson on Sunday referred to its statement issued on Saturday saying it will continue to support the investigation and Air India.
"We will defer to the AAIB to provide information about AI171, in adherence with the UN International Civil Aviation Organization protocol known as Annex 13," the spokesperson said in the emailed statement.
AAIB, in its report on Saturday, said that at this stage of investigation, "there are no recommended actions to B787-8 and/or GE GEnx-1B engine operators and manufacturers".
Air India's Dreamliner VT-ANB, which crashed on June 12, was powered by GEnx-1B engines.
According to the report, FAA issued Special Airworthiness Information Bulletin on December 17, 2018, regarding the potential disengagement of the fuel control switch locking feature.
"This SAIB was issued based on reports from operators of Model 737 airplanes that the fuel control switches were installed with the locking feature disengaged. The airworthiness concern was not considered an unsafe condition that would warrant airworthiness directive by the FAA," it said.
AAIB also said the fuel control switch design, including the locking feature, is similar on various Boeing airplane models including part number 4TL837-3D, which is fitted in B787-8 aircraft VT-ANB.
"As per the information from Air India, the suggested inspections were not carried out as the SAIB was advisory and not mandatory. The scrutiny of maintenance records revealed that the throttle control module was replaced on VT-ANB in 2019 and 2023.
"However, the reason for the replacement was not linked to the fuel control switch. There has been no defect reported pertaining to the fuel control switch since 2023 on VT-ANB," the report said.
After being in cut-off mode, the fuel control switches of the aircraft's two engines were turned on later but the London-bound aircraft could not get enough thrust and altitude before it crashed into a building in Ahmedabad killing 260 people.
Hashtags
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
India Today
40 minutes ago
- India Today
Pilots' union seeks role in Air India crash probe, may take legal route
Pilots' grouping ALPA-India on Sunday said it is mulling legal recourse to have its members as part of the investigation into the Air India's Boeing 787-8 plane crash, a day after alleging that AAIB's preliminary report suggests a bias towards pilot Airline Pilots' Association of India (ALPA-India) represents over 800 pilots of airlines and helicopter companies in the country. It is a member of the International Federation of Airline Pilots' Association (IFALPA), which claims to have 1 lakh pilots from across 100 countries as its the backdrop of the AAIB's preliminary report, representatives of ALPA-India will meet officials of the Directorate General of Civil Aviation (DGCA) on Monday to discuss various issues. "The preliminary report by the AAIB has been put up on the website. It does not have anyone's signature on it. We want transparency. We had asked for our representation in the investigation panel," ALPA-India President Sam Thomas told stressed that its members have domain expertise and can contribute meaningfully in the investigation of the Air India plane association is mulling legal recourse to ensure that its members are made a part of the investigation comments come at a time when people from certain quarters are opining that fuel switches could have been cut off by a pilot, a proposition that has been strongly rejected by pilots' Aircraft Accident Investigation Bureau (AAIB) in its preliminary report on the crash that killed 260 people on June 12 said the fuel switches to the engines were cut off within a gap of 1 second immediately after takeoff and caused confusion in the cockpit of Air India flight AI second largest airline by domestic market share, Air India is owned by the Tata cockpit voice recording, the 15-page preliminary report, released on Saturday, said one pilot asked why the switch was cut off and the other pilot responded that he did not do so."We are once again surprised at the secrecy surrounding these investigations. We are also reiterating the fact that suitably qualified personnel are not taken on board for these crucial investigations," ALPA-India said in a statement on Saturday."We feel that the investigation is being driven in a direction presuming the guilt of pilots and we strongly object to this line of thought," it had month, IFALPA offered its 'technical expertise' to the Indian civil aviation authorities in the Ahmedabad plane crash probe being conducted by the a letter to AAIB Director General G V G Yugandhar, the federation had said it was ready to provide expert technical and other forms of assistance, share global best practices and offer personnel to collaborate closely with the five-member team appointed by the AAIB is probing the crash, which is also the first where a Boeing 787 Dreamliner accident resulted in hull loss."Experienced pilots, engineers, aviation medicine specialist, aviation psychologist and flight recorder specialists have been taken on board as subject matter experts to assist the investigation in the area of their domain expertise," AAIB said in the preliminary report.- Ends
Time of India
44 minutes ago
- Time of India
Fuel switch locks safe: Boeing, US aviation organisation
Representative image WASHINGTON/NEW DELHI/MONTREAL: US Federal Aviation Administration (FAA) and Boeing have privately issued notifications that fuel switch locks on Boeing planes are safe, a document seen by Reuters showed and four sources with knowledge of the matter said. FAA's continued airworthiness notification on July 11 came after a preliminary report Friday into last month's Boeing 787-8 crash, which killed 260 people, raised questions over engine fuel cutoff switches. The notification to civil aviation authorities said: "Although the fuel control switch design, including locking feature, is similar on various Boeing aeroplane models, the FAA does not consider this issue to be an unsafe condition that would warrant an airworthiness directive on any Boeing airplane models. " When approached, the US FAA did not have anything to add beyond the notification. Boeing also referred to FAA's notification, which said the planemaker is not recommending any action, sources said. REUTERS
Time of India
7 hours ago
- Time of India
Questions mount over gaps, error in ‘opaque' AI prelim crash report
Kolkata: Veteran pilots from various airlines who reviewed the preliminary AI 171 crash report have questioned whether a software glitch or mechanical failure — which could cause fuel valves in a Boeing 787 Dreamliner to switch off — was ruled out before it was published. Tired of too many ads? go ad free now An experienced pilot said it was curious that the report did not even mention this possibility. "On the B 787, fuel shut-off valves are controlled via remote data units (RDUs). While the left and right engines have independent RDUs, power is supplied via remote power distribution units (RDPUs), which are software-based electrical substations. Since RCDs and RDPUs are networked, a common software error or network fault could potentially impact both engines," the pilot said. Another industry veteran pointed out that valve closure due to power interruption or software glitches was flagged during the initial rollout of B 787. Pilots have also flagged issues in the report like incorrect and incomplete information, which has sparked speculation about pilot culpability. While appreciating the move to publish a report on the primary findings, pilots pointed out that even basic information, like the flying hours of Captain Sumeet Sabharwal mentioned, was erroneous. Sabharwal's airline transport pilot licence was issued on May 14, 2021. With DGCA stipulating a maximum of 1,000 flying hours a year, he could have 4,000 hours under his belt as pilot in charge by May 2025. The report, however, logs this at 8,260 hours. Pilots also allege that the report is deliberately opaque on several issues and uses words and phrases selectively to not only hint at human error but insinuate ill intent behind the accident. Tired of too many ads? go ad free now They make three arguments to substantiate this. First, just one brief exchange between the captain and the first officer is presented in the report in indirect speech, instead of releasing the entire transcript of the interaction in the 21 minutes between when the flight departed the parking bay and when it crashed. The most crucial section is the 1 minute 22 seconds between ATC takeoff clearance and the Mayday call. "Why is the transcript of the conversation from the cockpit voice recorder not given in its entirety so that the context can be understood? The report states: 'In the cockpit, in the cockpit voice recording, one of the pilots is heard asking the other why did he cut off. The other pilot responded that he did not do so'," a pilot said. Pilots also pointed to the use of the phrase "transition" of fuel switches instead of attributing it to human action, and said it was an insinuation that the men in the cockpit were responsible for the catastrophic accident. A captain said: "In an extremely challenging and unprecedented situation, these men were trying their best to achieve the impossible. They were too close to the surface for recovery, which they did attempt per the checklist, which is a testament to their sound and calm minds." He said that in the case of dual engine loss, the full authority digital engine control (FADEC) that optimises engine performance is reset using the following procedure: start switches on; shift thrust lever to idle; shift fuel switches from run to cut off to run. "This is exactly what the pilots appear to have done and managed to get one engine to start revving up but rammed into a building before the engine could spool up," he said. Airline Pilots Association of India president Captain Sam Thomas said the tone and direction of the investigation suggested a bias towards pilot error. "ALPA-I categorically rejects this presumption and insists on a fair, evidence-based inquiry," he said.
