logo
Ford Just Issued Another Massive Recall. And It Doesn't Even Have a Fix Yet

Ford Just Issued Another Massive Recall. And It Doesn't Even Have a Fix Yet

Motor 110-07-2025
Ford Motor Company
is recalling 850,318 vehicles due to a potential issue with the fuel pump. The recall affects a range of Ford and
Lincoln
models from the 2021-2023 model years. The vehicles could suffer from a low-pressure fuel pump failure, which could starve the engine of gas and cause it to stall.
According to the
recall report
, internal contamination of the low-pressure fuel pump jet could lead to a loss of flow and pressure, increasing the "sensitivity to vapor lock." Owners may experience reduced power or poor engine performance, like misfiring or rough running, before the fuel pump fails.
The recall affects some of Ford's most popular and iconic models, like the
Bronco
,
Explorer
,
Mustang
, and
F-150
, with the popular pickup accounting for more than half of the batch. It also includes the
Super Duty
, the
Expedition
, the
Lincoln Aviator
, and the
Lincoln Navigator
.
Ford first learned of a potential problem in September 2022 when its Critical Concern Review Group (CCRG) initiated an investigation. The automaker had seen an increase in the number of warranty claims related to the fuel delivery modules on certain 2021-2022 vehicles. According to the recall notice, these vehicles had a "specific variant of low-pressure fuel pump and jet pump."
Here's the full list:
Year/Model
Number Affected
2021-2023 Ford Bronco
109,881
2022-2022 Ford Expedition
32,470
2021-2023 Ford Explorer
76,089
2021-2023 Ford F-150
455,261
2021-2022 Ford Mustang
24,790
2021-2023 Ford Super Duty
113,396
2021-2023 Lincoln Aviator
23,073
2021-2022 Lincoln Navigator
14,358
Ford's teardown analysis uncovered contamination blocking the jet pump orifices; however, the automaker couldn't confirm the source. The number of warranty claims declined after the supplier "implemented several corrective actions from December 2021 through September 2022" to reduce contamination.
In July 2023, Ford's CCRG closed its investigation after confirming the supplier corrected the issue. However, a year later, the National Highway Traffic Safety Administration began to evaluate six consumer complaints about their 2021 Broncos losing power. The CCRG opened a new investigation in April 2025 and discovered in May that warranty claims increased in the warm-weather states and during the summer months.
Then, last month, Ford found the problem. The supplier made changes to the jet pump production process in July 2021 that resulted in lower clearances. As of June 6, there have been 1,860 warranty claims, 57 customer service reports, and 28 field reports related to the issue. However, the automaker is unaware of any accidents or injuries caused by the problem.
Ford does not have a remedy yet for the affected vehicles. It's "under development," according to the recall report. Once it has a fix, it'll notify owners by mail, instructing them to take their vehicle to a dealer for repair. Owners should begin receiving initial notices next week.
More Ford Recall News:
Ford Recalls Another One Million Vehicles
Ford Is Facing the Second-Largest Recall Fine In NHTSA History
Get the best news, reviews, columns, and more delivered straight to your inbox, daily.
back
Sign up
For more information, read our
Privacy Policy
and
Terms of Use
.
Source:
National Highway Traffic Safety Administration
Share this Story
Facebook
X
LinkedIn
Flipboard
Reddit
WhatsApp
E-Mail
Got a tip for us? Email:
tips@motor1.com
Join the conversation
(
)
Orange background

Try Our AI Features

Explore what Daily8 AI can do for you:

Comments

No comments yet...

Related Articles

This Bezos-backed EV startup is betting you'll pay extra for a stereo in your petite pickup
This Bezos-backed EV startup is betting you'll pay extra for a stereo in your petite pickup

Yahoo

time21 minutes ago

  • Yahoo

This Bezos-backed EV startup is betting you'll pay extra for a stereo in your petite pickup

By Kalea Hall and Nora Eckert (Reuters) -When Will Haseltine saw images online of a small, boxy electric pickup from startup Slate Auto this past spring, he got on the waitlist right away. The sparse interior and crank windows reminded him of the no-frills pickups he grew up around in Memphis, Tennessee – but he was most enamored with the sub-$20,000 price tag. That price, though, factored in a $7,500 federal tax break, which is set to expire Sept. 30, a casualty of the budget package U.S. President Donald Trump signed into law earlier this month. Now Haseltine isn't sure the truck will fit his budget when it comes out, expected late next year. 'The Slate was the first time that I looked at a car, wanted it, and could also really make it happen," said Haseltine, a 39-year-old musical instrument technician. Without the tax credit, he said: "That's just plain too much." Michigan-based Slate has raised $700 million from investors, including founder Jeff Bezos, and has racked up more than 100,000 reservations for its cars. But the company is launching into a tough U.S. market. A few years ago, the electric-vehicle space was awash in hopeful entrepreneurs looking to cash in on the global transition to electric cars. But U.S. EV sales growth has cooled as consumer interest has faded. The loss of federal tax breaks will further hurt demand, auto executives and analysts predict. Like other EV startups, Slate likely faces a long road to profitability. The EV business has proven to be a money loser for most industry players, partly because batteries remain relatively expensive. Even in China, where smaller, inexpensive EVs have proliferated and companies enjoy a cost advantage over Western automakers, most are unprofitable. Slate founders believe the company can overcome those obstacles by offering something that is in short supply in today's U.S. car market: affordability. The average new-vehicle selling price is above $45,000. 'We are building the affordable vehicle that has long been promised but never delivered,' Slate CEO Chris Barman said at a Detroit conference in July. The company has a chance to fill a void left by Tesla, which has backtracked on plans to introduce a mid-$20,000s electric vehicle. The startup has taken a bare-bones approach to its two-seat pickup, which is slightly smaller than a Honda Civic hatchback. How bare-bones? A stereo and power windows will cost extra. Slate hasn't disclosed the cost of such add-ons. 'IT'S A COOL IDEA' Slate's creation started with an idea from Miles Arnone, the CEO of Re:Build Manufacturing, a Massachusetts-based startup that includes several former Amazon employees. Arnone believed workers needed better access to affordable vehicles. Arnone shared his idea with Jeff Wilke, the company's chairman and a former Amazon executive, and eventually, a small team was formed. The group hired Barman, who spent most of her career as an engineering executive at Fiat Chrysler, now part of Stellantis. Barman told Reuters recently that Slate will be able to absorb the loss of the $7,500 tax credit because the truck's price still will undercut competitors. The company plans to build the pickup at an old catalog factory in Warsaw, Indiana. Executives are taking steps to hold down costs, starting with a simplified design that uses about 500 parts in the truck's assembly, compared with a few thousand for a traditional truck. The plan to build all of its trucks in a basic package – what the company calls a 'SKU of one' – allows customers to choose to add a stereo, center console, special lighting, and other features later. The pickup will be built with composite body panels in gray, with an option for a vinyl wrap. That will sidestep the need for a paint shop, which is one of the most expensive investments in a typical car factory. Slate's minimalist approach is a leap of faith that Americans will forgo creature comforts they have been increasingly willing to splurge on. Last year, U.S. buyers spent 33% above the base price on average, springing for higher-end trim packages and extra features, according to . That was up from 28% in 2014. But there is mounting evidence that new cars are becoming out of reach for many Americans. That could worsen under the effects of the Trump administration's tariffs, which threaten to increase prices on popular budget cars imported from Mexico, Korea and elsewhere. From that standpoint, Slate's price-conscious pickup might be hitting at the right time, said Paul Waatti, director of industry analysis at AutoPacific. 'There's a growing appetite, especially among younger drivers, for vehicles that are more honest, more modular and less over-engineered,' he said. 'Slate taps right into that.' Traditional automakers and startups have found mixed success rolling out larger electric pickup trucks in recent years. Now, startups like Slate and California-based Telo are focusing on smaller electric pickups. In a town hall meeting in early May, Ford CEO Jim Farley and Executive Chair Bill Ford told employees they admired the company's customer-centered ethos and focus on affordability. Tim Kuniskis, Stellantis' head of American brands, called Slate 'super interesting' at a June event, while also questioning how affordable it would be for some shoppers once they added all the options they wanted. 'The idea behind it, we've talked about that idea a million times,' he said. "It's a cool idea.' Connectez-vous pour accéder à votre portefeuille

I'll never have a car payment. Here's my secret.
I'll never have a car payment. Here's my secret.

USA Today

time22 minutes ago

  • USA Today

I'll never have a car payment. Here's my secret.

Driving a beat-up used car wasn't always a choice, but it became my preference. Older, beat-up cars aren't for everyone, and vehicle safety should always be paramount. But it's slim pickings here. Driving a beat-up used car wasn't always a choice, but it became my preference. During lean financial times in my life, avoiding a monthly car payment was key. That meant driving a paid-off SUV all the way into the ground, and then turning to the used auto auction circuit for a series of junkers that were surprisingly enjoyable to drive around. I'm lucky enough to have an uncommonly short commute, a complete lack of interest in modern vehicle aesthetics, a durable ego and a dependable auto shop in my neighborhood. Older, beat-up cars aren't for everyone, and vehicle safety should always be paramount. But it's slim pickings out there. Detroit Free Press autos writer Jamie LaReau reported recently that the average list price for a 3-year-old vehicle is now $32,635, an infuriating $9,476 more than it was six years ago. That's a lot of money. And for the driver who doesn't mind a little rust around the edges, there are affordable options out there. You might just need to dig up and dust off that old cassette tape collection to keep the cruising music playing. Here's my case for the humble clunker car: 1. Clunker cars save me money A couple of decades ago, Michiganders could lease a decent new car for $200 to $300 a month, often without a down payment. Sometimes even less. Those days appear to be behind us. So in 2021, after my 2008 Kia Sportage bit the dust, I shelled out $1,500 at auction for a bright red 1998 Toyota Camry. (Sorry, union die-hards. I do now own a Ford.) I dug some old cassette tapes out of my parents' basement – The Fugees, The Temptations, Michael Jackson, Fairuz. I spent another $1,500 on repairs and drove that thing happily for two and a half years. That comes out to $100 a month. And the insurance was dirt cheap. I sold it to a neighbor for $400 – a bargain because I like my neighbor – and purchased another, slightly better vehicle, again at auction. It's a formula I plan to keep following, gradually upgrading along the way, and flaunting my savings to anyone who'll listen. Opinion: I'm taking a stand against jacked-up airline fees by taking the middle seat 2. Older cars help me avoid touchscreen frustrations I like buttons and knobs in a dashboard. If I have to scroll and swipe and tap my way to turning on a defogger, I'm liable to curse and spit my way right into a distracted-driving tragedy. I've seen dashboard computer systems malfunction to the point where the driver was left stranded. I've had my behind uncomfortably toasted by heated seats. And I've spent way too much time trying and failing to get my phone to connect via Bluetooth to a modern car stereo system. Modern amenities aren't all they're cracked up to be. Certainly not at $500 a month. 3. Anything can go wrong. This keeps me ready. I like to keep close to the reality that just about anyone can go broke at the drop of a hat. A cancer diagnosis. A bad accident. A stock market crash. A sports betting addiction. There are 1,001 ways personal finances can go terribly wrong very quickly, necessitating serious lifestyle changes. I want to be sure I can handle it when catastrophe comes calling, and nothing says "ready for poverty" quite like having to reach through the window to open your car door. 4. Beater cars are easy to buy Compared with your typical dealership experience, which can be lengthy and stressful, buying a beater at auction or directly from another owner can be surprisingly smooth and quick. There are online and in-person auto auctions all over Michigan, just about every week. I've purchased two vehicles, and a whole lot of other fun junk, via a Kalamazoo-based online auction house with a warehouse and lot in Garden City, where vehicles can be inspected in-person before online bidding begins. (I didn't inspect either vehicle before buying them, but I'm a madman.) Opinion: Waymo cars get torched by LA protesters, burning Google – an immigration ally All it takes is creating an account, and using some restraint when it comes to bidding. It's easy to get caught up in the competition of trying to outbid everyone else, which can lead to overpaying. Going in with a maximum price in mind is key. Auction houses typically charge a 15%-18% premium on the final bid. Getting insurance and making a cash payment put the keys in your hands. Banks and credit unions won't likely offer auto loans for auction purchases, but they may provide personal loans. One key strategy when bidding in any online auction: Wait until the very end of the auction time frame to place your bid. That's when all the serious buyers make their bids. Jump in too early and turn away, and someone will swipe that bargain right out of your hands. 5. Owning a hooptie provides life lessons The first order of business after buying that hooptie is taking it to an auto shop for a safety inspection. Forcing myself through the process of finding a trustworthy repair shop, learning about the most commonly needed replacement parts and figuring out how to diagnose routine problems have seriously enriched my automobile knowledge. Opinion: When will we have flying cars? Trump should pump the brakes on testing air taxis. The experience has given me the ability to make some of the simpler fixes entirely on my own. Shopping junkyards for parts is next on my personal syllabus of Jalopy Maintenance 101. I grew up in Dearborn and live in Detroit. Not being much of a car enthusiast has always left me a bit insecure about my Motor City identity. Learning the basics of auto repair fixed that. Even if I may never fully appreciate cars. 6. Honestly? Driving a junker is a little fun. The SUV I drive now isn't a regular Ford Explorer. It's a 2014 Ford Explorer Police Interceptor with 157,000 hard-earned miles. And it was previously owned by the Westland Police Department. It has no back seats – plenty of room for activities. It has a pair of bright spotlights, which I've used to illuminate basketball hoops and outdoor work areas at night. It's also very fast. I've yet to find a safe way to really make use of that attribute. But speedy acceleration does come in handy when merging onto highways. And the CD player has given me an excuse to pull out the old library of 1990s and early-2000s treasures. 7. I flabbergast my friends and family My parents certainly don't get it. They know I could probably afford a somewhat nicer car, and I think they're embarrassed by my choice of vehicle. But the children in my family love playing in the old cop car. Traffic tends to slow down around me because the shape of my civilianized vehicle still fools a lot of drivers. It's big and intimidating, so I pull up slow and quiet on friends to give them a good scare. Dents and chips mean absolutely nothing, so a bump into a pole or a scrape against a tree branch are good for a laugh. The Camry may have been an even better conversation piece. It once left me briefly stranded on Belle Isle, refusing to start after a Free Press softball game. But after learning a quick tip via YouTube, I opened up the hood and used a softball to bang on the starter a few times. The delightfully unsophisticated trick had the everlasting Toyota engine purring like a kitten in minutes. It was an unlikely triumph that lifted my spirits for days. "That thing's gonna last you forever," I heard over and over at drive-thru windows and toll booths. It didn't. At least not in my possession. But the memories will. Khalil AlHajal is deputy editorial page editor of the Detroit Free Press, where this column originally appeared. Contact him at kalhajal@

Why Tesla's valuation is hard to read as Musk's EV empire falters
Why Tesla's valuation is hard to read as Musk's EV empire falters

Yahoo

time25 minutes ago

  • Yahoo

Why Tesla's valuation is hard to read as Musk's EV empire falters

Prickly billionaire Elon Musk is at a crossroads with Tesla (TSLA) — and investors are shouldering the outsized risk. "I think we are in the transition phase, so it's a very critical phase for Tesla at the moment," Gradient Investments' Lisa Schreiber said on Yahoo Finance's Opening Bid (watch above). On July 23, Tesla reported much weaker second quarter earnings compared to a year ago. During the earnings call, Musk cautioned about headwinds and shared that ride-hailing and autonomous features will be a key focus for the company going forward. Shares fell directly after the earnings announcement and closed down 8.2% on Thursday. Tesla remains an innovator, with robots and AI in its portfolio. Its EV business, however, is sharply declining as competition rises and backlash grows against Musk's politics. The expiration of a $7,500 federal credit for EVs won't help matters, either. "When we look at valuation, investors do not know exactly how to value [Tesla]. Is it an EV maker? Is it more than that? The thing is, it's not just an EV play anymore," Schrieber said. "But it's also not a robotaxi [and] robot company already. So we have struggles here." To Schrieber's point, Tesla's stock trades more like a hot tech player trying to take on juggernauts like Nvidia (NVDA). Shares trade at 161 times the estimated forward price to earnings. (Nvidia, with much stronger growth, trades around 55 times.) Ford (F), a pure-play automaker, trades at 9.6 times. Meanwhile, some perceive Tesla as a company that isn't sure what it wants to be when it grows up. The innovation around autonomous driving is noteworthy, but the waiting can make even the most patient investor antsy. "Especially with Tesla, we have to be a little bit careful," Schreiber said, noting that Musk has a history of huge promises but delayed launches. The robotaxi, for instance, launched this past June in Austin, Texas. William Blair analysts Jed Dorsheimer and Mark Shooter, who rate Tesla's stock at Market Perform, noted that rival company Google's (GOOG) Waymo robotaxi "represents a six-year head start." "We think the training wheels will get taken off quickly and the pace at which robotaxi scales will surprise the upside," the pair wrote. "Although maybe not to half of Americans by the end of the year." During Tesla's earnings call, Musk also discussed humanoid robots, AI, and their integration into the vehicle fleet, calling the company's cars "essentially a four-wheeled robot." "Optimus is a robot with arms and legs," he said. "So the same principles that apply to optimizing AI inference of the car applied to Optimus because they're both really robots in different forms." If Musk and Co. can deliver, investors like Schreiber will likely be among the first in line to celebrate, but for the time being, they are content to watch and wait. "I think we have to be a little bit careful here," she said. "For us to be able to be a buyer here, we would need to see some foot on the ground and we would need to see some realization first."Grace Williams is a writer for Yahoo Finance. Error in retrieving data Sign in to access your portfolio Error in retrieving data Error in retrieving data Error in retrieving data Error in retrieving data

DOWNLOAD THE APP

Get Started Now: Download the App

Ready to dive into a world of global content with local flavor? Download Daily8 app today from your preferred app store and start exploring.
app-storeplay-store